Abstract:Suspensions were prepared by mixing hydrophilic fumed silica (FS) with low-molecular polyethylene glycol (PEG, weight-averaged molecular weight 400). By differential scanning calorimeter and broadband dielectric spectrometer, influences of FS volume fraction (phi) on alpha-relaxation and crystallization behaviors of bulk PEG phase were investigated. Furthermore, influences of phi on the linear and nonlinear rheology behaviors of the suspensions were also investigated using stress-controlled rheometer. For the bulk PEG phase, alpha-relaxation is retarded and glass transition temperature (T-g) is increased due to the addition of FS. On the other hand, FS significantly retard the diffusion of global PEG molecules, which leads to a great increase in viscosity of the suspensions along with significant reductions in crystallization and fusion enthalpy of the bulk PEG phase. The suspensions demonstrate different rheology and crystallization behaviors with varying phi. The low-filled suspensions exhibit an apparent sol-like rheological response, in which FS plays a nucleating role to promote PEG crystallization. However, the high-filled suspensions apparently behave like gels, in which FS restrains the chain diffusion and crystallization. The role of FS changes in the vicinity of phi = 0.16, where the system undergoes an apparent sol-to-gel transition. In the close vicinity of this transition, the nonlinear dynamic rheology shows the most obvious strain hardening, while the linear dynamic rheology demonstrates the most significant frequency-dependence. Due to the extremely complicated nonlinear rheological response of the suspensions, it is hard to observe the pure hydrodynamics region experimentally, and in the frequency range achieved, complex viscosity (eta*) as a function of phi at given frequencies does not fit classical hydrodynamics equations that do not consider the effect of nanoparticles on the polymer chains diffusion. To account for the effect of nanoparticles on the diffusion of PEG chains, data of liner dynamic rheology of the suspensions are shifted horizontally and vertically to create master curves with pure PEG as the reference. The creation of master curves reveals that FS greatly retards the diffusion of global PEG chains in the constrained bulk phase, which plays a major role in the reinforcement and dissipation of the suspensions. In addition to the dynamically retarded bulk PEG chains, both the inter-particle friction in the low-filled sols and the in-cage rattling motion of nanoparticles in the high-filled gels additionally contribute to the dissipation behavior of the suspensions, resulting in the complicated dynamic rheological behavior.

Adjustable rheology of fumed silica dispersion in urethane prepolymers: Composition-dependent sol and gel behaviors and energy-mediated shear responses

Rheology of Fumed Silica/Polydimethylsiloxane Suspensions

Phase Transition, Equation of State, and Limiting Shear Viscosities of Hard Sphere Dispersions

Molecular Relaxation and Rheological Behaviors of Fumed Silica/Low-molecular Weight Polyethylene Glycol Suspensions

Rheology of Fumed Silica/polypropylene Glycol Dispersions

Molecular Relaxation and Rheological Behaviors of Silica/Poly(propylene Oxide)dispersions

Extensional rheology of shear-thickening fumed silica nanoparticles dispersed in an aqueous polyethylene oxide solution

Rheology of fumed silica nanoparticles/partially hydrolyzed polyacrylamide aqueous solutions under small and large amplitude oscillatory shear deformations

On the rheological properties of Silica – Poly(ethylene-oxide) dispersions: "Shake-gels" II The effect of silica concentration and molecular weight of polymer

Viscoelastic Study of Single Chain Cyclized Polymeric Nanoparticles and Linear Polymers Blends

Effect of particle stiffness and surface properties on the nonlinear viscoelasticity of dense microgel suspensions

Linear Rheology of Natural Rubber Compounds Filled with Silica, Short Nylon Fiber or Both

Relationship between Microstructure, Dynamics, and Rheology in Polymer-Bridging Colloidal Gels

Rheological Study of the Sol-Gel Transition of Hybrid Gels

Interaction and Microstructure of Polyurethane/Silica Hybrid Films Prepared by Sol-Gel Process

Rheological behavior of fumed silica filled polyethylene oxide

Effect of addition of silicone oil on the rheology of fumed silica and polyethylene glycol shear thickening suspension

Dynamic shear rheology of colloidal suspensions of surface-modified silica nanoparticles in PEG

Interfacial Structure and Rheology of Fumed Silica Filled Polar Oligomer Nanocomposites

Rheological Behavior of Aqueous Organosilicone Resin Emulsion Stabilized by Colloidal Nanosilica Particles.