Investigation on dioxins emission characteristic during complete maintenance operating period of municipal solid waste incineration
Heng Xia,Jian Tang,Loai Aljerf,Tianzheng Wang,Junfei Qiao,Qindong Xu,Qiang Wang,Prince Ukaogo
DOI: https://doi.org/10.1016/j.envpol.2022.120949
IF: 8.9
2022-12-28
Environmental Pollution
Abstract:The dioxins (DXN) are a set of pollutants encompass polychlorinated dibenzo-p-dioxin/dibenzofuran (PCDD/F), their emissions from municipal waste incineration processes (MSWI) are normally detected under steady operating conditions. However, limited studies have focused on the PCDD/F emission characteristics under a complete maintenance operating period (CMOP), which includes shut-down, cooling, maintenance, heating, startup, and normal operations. In this article, the shutdown process (SDP) starts from the normal operation, followed by shutdown, and then cooling; while the startup process (SUP) commences from heating, followed by startup, and then normal operation. The detection and analysis were conducted at the SDP and SUP stages. The PCDD/F mass and total toxic equivalent quantity (TEQ) concentrations were measured in the flue gas and bag filter fly ash (BF-FA) during a CMOP of Beijing MSWI plant. The highest PCDD/F concentrations in the flue gas were found in the "cooling" and "startup" phases; in the FA, this condition occurred in the "startup" phase. Further, the results show that the most heightened concentrations were observed for 5–6 chlorinated PCDF and 4–5 chlorinated PCDD among the 17 PCDD/F congeners in most cases. More importantly, the air pollution control devices (APCDs) which include activated carbon, lime, and BF, have high removal efficiency for PCDD/F (especially PCDD) during the "startup" phase. APCDs also easily release a considerable amount of PCDD/F because of the memory effect, which emits more PCDD/F at the "shutdown" phase than at the "startup" one. Besides, the annual PCDD/F emission in the flue gas of the MSWI plant was estimated to be 67.72 mg I-TEQ, of which the emission accounts for approx. 20% during the CMOP. Moreover, the experiment shows that the PCDD/F emissions of the MSWI plant in Beijing under unsteady conditions are more miniature than those reported earlier in other areas.
environmental sciences