Abstract:With the advantages of non-contact, compatibility, no chemical effect and safety, acoustic levitation of object has great potential to apply in chemistry, biology, medicine field and micro robots. Suspension to large particle higher than the half wavelength( $0.5\lambda $ ) of sound wave, is a challenge technology in micro-nanoscale manipulation. An increased large quantity probes, double sided and four sided phased array with virtual vortex can provide higher capture power, control ability and stability of particle fixation and the manipulation. However, for a limited confined space, the additional probes and sided phased array emission and receiving device is hard to be established and applied. Additional probes and sided ultrasonic phased array requires higher processing ability of MCU (Micro Control Unit) and the quantities of transducers. Further, multiparticles suspension is rare to be reported. In this study, a relatively simple suspension device of one sided concave spherical transducer array is designed, aiming to levitate a large particle and multi-particles. Based on the one sided acoustic field simulation of ultrasonic array, the optimized structure of open spherical sector (OSS) is constructed to establish levitation device. Experimental platform integrating FPGA controller, amplifier and impedance matching is developed to drive the transducer arrays, where a polystyrene particle with 6 mm ( $0.71\lambda $ ) diameter is successfully levitated. The virtual twin trap sound pressure of transducer array is measured to evaluate the particle stability. Experiments demonstrate the correctness of virtual twin trap acoustic field analysis, the feasibility in the manipulation to the large particle and multi-particles by acoustic trap.

Rapid rise of planar object by near-field acoustic levitation on recessed acoustic radiation surface

Theoretical and experimental examination of near-field acoustic levitation

Modeling and Experimental Study on Near-Field Acoustic Levitation by Flexural Mode

Study on Transient Properties of Levitated Object in Near-Field Acoustic Levitation

Dynamic Coupling and Experimental Study on Flexural Transducer Used in Near Field Acoustic Levitation

Nonlinear Restoring Forces and Geometry Influence on Stability in Near-Field Acoustic Levitation

Noncontact Transportation of Planar Object in an Ultrasound Waveguide

Acoustic Radiation Simulation and Pre-Stress Effect on Compact Acoustic Levitation Platform

High speed surface acoustic wave and laterally excited bulk wave resonator based on single-crystal non-polar AlN film

Acoustic levitation of liquid drops: Dynamics, manipulation and phase transitions

Lateral Movement of Particles in a Levitating Acoustic Field

Optical measurement of acoustic radiation pressure of the near-field acoustic levitation through transparent object

Validation of finite element analysis strategy to investigate acoustic levitation in a two-axis acoustic levitator

Enhanced standing-wave acoustic levitation using high-order transverse modes in phased array ultrasonic cavities

Three-dimensional Mid-air Acoustic Manipulation by Ultrasonic Phased Arrays

Direct measurement of forces in air-based acoustic levitation systems

Measuring Velocity of Sound by Using Acoustic Levitation

Acoustic Levitation for Large Particle Based on Concave Spherical Transducer Arrays

Modeling Characterization and Optimization Design for PZT Transducer Used in Near Field Acoustic Levitation

Analysis of dynamic levitation process of the particle chain in a nonlinear standing wave field

Analytical and experimental results: creation of a duffing acoustic nonlinear oscillator at low amplitudes