Abstract:Dry Anaerobic Digestion (AD) presents different advantages if compared to wet AD, i.e. smaller reactor size, lesser water addition, digestate production and pretreatment needed, although several studies have demonstrated that water promotes substrate hydrolysis and enables the transfer of process intermediates and nutrients to bacterial sites. To better understand the role of water on AD, dry and semidry digestion tests of selected complex organic substrates (food waste, rice straw, carrot waste), with various TS contents of the treated biomass have been carried out in the present study. The results confirm that water plays an essential role on the specific methane production rate, final methane yield and Volatile Solids (VS) degradation. The final methane yield in semi-dry and dry conditions was 51% and 59% lower for rice straw and 4% and 41% lower for food waste, respectively, if compared with wet conditions. Inhibition tests, based on Volatile Fatty Acid (VFA) analysis, were carried out to investigate the specific inhibition processes that take place with the selected substrates at different TS contents. In wet AD of carrot waste no VFA accumulation was found, and all VFA concentrations were lower than the inhibition limits. A direct correlation between TS content and total VFA (TVFA) concentration was noticed for rice straw and food waste AD. For rice straw a maximum TVFA concentration of 2.1 g/kg was found in dry condition, 1 g/kg in semidry conditions and 0.2 g/kg in wet conditions, whereas for food waste the TVFA concentration was 10 g/kg in dry condition, 9 g/kg in semidry conditions and 3 g/kg in wet conditions. A Mathematical model of complex organic substrate AD in dry and semidry conditions has been proposed to simulate the effect of TS content on the process. The data obtained from batch experiments, in terms of methane production and VFA concentrations, were used to calibrate the proposed model. The kinetic parameters of VFA production and degradation, calibrated using the experimental data, resulted highly dependent on the TS content and different from wet AD literature values. This is due to VFA accumulation in dry conditions, which implies higher values of the inhibition factors introduced in the model. Finally, as dry AD takes usually place in Plug Flow (PF) reactors, an historical and critical review on the role of hydrodynamics in PF bioreactors has been carried out

Simulation of anaerobic co-digestion of steam explosion pulping wastewater with cattle manure: Focusing on degradation and inhibition of furfural

Anaerobic Co-Digestion of Municipal Biomass Wastes and Waste Activated Sludge: Dynamic Model and Material Balances

Effects of Furan Derivatives on Biohydrogen Fermentation from Wet Steam-Exploded Cornstalk and Its Microbial Community.

The synergistic effect of potassium ferrate and peroxymonosulfate application on biogas production and shaping microbial community during anaerobic co-digestion of a cow manure-cotton straw mixture

Mathematical modeling of methane production and sulfate reduction in upflow anaerobic sludge blanket reactors: Calibration, validation and prediction of reciprocal effects

Semi-continuous mesophilic-thermophilic two-phase anaerobic co-digestion of food waste and spent mushroom substance: Methanogenic performance, microbial, and metagenomic analysis

A dynamic simulation of methane fermentation process receiving heterogeneous food wastes and modelling acidic failure

Deciphering Fe@C amendment on long-term anaerobic digestion of sulfate and propionate rich wastewater: Driving microbial community succession and propionate metabolism

Modeling of two-phase anaerobic process treating traditional Chinese medicine wastewater with the IWA Anaerobic Digestion Model No. 1.

Model Development for Anaerobic Digestion of Cellulose under Simulated Landfill Conditions

Kinetic modelling and synergistic impact evaluation for the anaerobic co-digestion of distillers' grains and food waste by ethanol pre-fermentation

Modeling the Performance of Full-Scale Anaerobic Biochemical System Treating Deinking Pulp Wastewater Based on Modified Anaerobic Digestion Model No. 1

Discovery of new strains for furfural degradation using adaptive laboratory evolution in Saccharomyces cerevisiae

A novel approach for the fractionation of organic components and microbial degraders in ADM1 and model validation based on the methanogenic potential

Application of anaerobic digestion model No. 1 for simulating fermentation of maize silage, pig manure, cattle manure and digestate in the full-scale biogas plant

Anaerobic Co-Digestion of Food Waste with Sewage Sludge: Simulation and Optimization for Maximum Biogas Production

Bio-methanation tests and mathematical modelling to assess the role of moisture content on anaerobic digestion of organic waste

Simulation of integrated anaerobic digestion-gasification systems using machine learning models

Links between carbon/nitrogen ratio, synergy and microbial characteristics of long-term semi-continuous anaerobic co-digestion of food waste, cattle manure and corn straw

Model-Based Feasibility Assessment of Membrane Biofilm Reactor to Achieve Simultaneous Ammonium, Dissolved Methane, and Sulfide Removal from Anaerobic Digestion Liquor

A Model For Anaerobic Degradation Of Municipal Solid Waste