Abstract:Dry Anaerobic Digestion (AD) presents different advantages if compared to wet AD, i.e. smaller reactor size, lesser water addition, digestate production and pretreatment needed, although several studies have demonstrated that water promotes substrate hydrolysis and enables the transfer of process intermediates and nutrients to bacterial sites. To better understand the role of water on AD, dry and semidry digestion tests of selected complex organic substrates (food waste, rice straw, carrot waste), with various TS contents of the treated biomass have been carried out in the present study. The results confirm that water plays an essential role on the specific methane production rate, final methane yield and Volatile Solids (VS) degradation. The final methane yield in semi-dry and dry conditions was 51% and 59% lower for rice straw and 4% and 41% lower for food waste, respectively, if compared with wet conditions. Inhibition tests, based on Volatile Fatty Acid (VFA) analysis, were carried out to investigate the specific inhibition processes that take place with the selected substrates at different TS contents. In wet AD of carrot waste no VFA accumulation was found, and all VFA concentrations were lower than the inhibition limits. A direct correlation between TS content and total VFA (TVFA) concentration was noticed for rice straw and food waste AD. For rice straw a maximum TVFA concentration of 2.1 g/kg was found in dry condition, 1 g/kg in semidry conditions and 0.2 g/kg in wet conditions, whereas for food waste the TVFA concentration was 10 g/kg in dry condition, 9 g/kg in semidry conditions and 3 g/kg in wet conditions. A Mathematical model of complex organic substrate AD in dry and semidry conditions has been proposed to simulate the effect of TS content on the process. The data obtained from batch experiments, in terms of methane production and VFA concentrations, were used to calibrate the proposed model. The kinetic parameters of VFA production and degradation, calibrated using the experimental data, resulted highly dependent on the TS content and different from wet AD literature values. This is due to VFA accumulation in dry conditions, which implies higher values of the inhibition factors introduced in the model. Finally, as dry AD takes usually place in Plug Flow (PF) reactors, an historical and critical review on the role of hydrodynamics in PF bioreactors has been carried out

Application of Anaerobic Digestion Model No. 1 for modeling anaerobic digestion of vegetable crop residues: Fractionation of crystalline cellulose

Examining a Pretty Simple and Low Cost Method for Modeling of Biogas Production from Biodegradable Solids

A First-Order Kinetic Model for Simulating the Aerobic Degradation of Municipal Solid Waste.

Modeling anaerobic digestion of aquatic plants by rumen cultures: cattail as an example.

Model Development for Anaerobic Digestion of Cellulose under Simulated Landfill Conditions

Stochastic model of lignocellulosic material saccharification

Study on Anaerobic Digestion of Cellulosic Waste and Its Dynamics Model

A novel approach for the fractionation of organic components and microbial degraders in ADM1 and model validation based on the methanogenic potential

Simulation models of microbial community, pH, and volatile fatty acids of anaerobic digestion developed by machine learning

Parameter Determination and Validation for a Mechanistic Model of the Enzymatic Saccharification of Cellulose-Iβ.

Modeling of two-phase anaerobic process treating traditional Chinese medicine wastewater with the IWA Anaerobic Digestion Model No. 1.

Application of a simplified ADM1 for full-scale anaerobic co-digestion of cattle slurry and grass silage: assessment of input variability

Bio-methanation tests and mathematical modelling to assess the role of moisture content on anaerobic digestion of organic waste

Modeling key intermediates during anaerobic digestion of lipid rich kitchen waste with an extended ADM1

A Challenge in Anaerobic Digestion of Swine Wastewater: Recalcitrance and Enhanced-Degradation of Dietary Fibres

Modification of Anaerobic Digestion Model No.1 with Machine Learning Models Towards Applicable and Accurate Simulation of Biomass Anaerobic Digestion

Modifications to the anaerobic digestion model no. 1 (ADM1) for enhanced understanding and application of the anaerobic treatment processes - A comprehensive review

Modeling the microbial pretreatment of camelina straw and switchgrass by Trametes versicolor and Phanerochaete chrysosporium via solid-state fermentation process: A growth kinetic sub-model in the context of biomass-based biorefineries

Mathematical Modeling of Solid-State Anaerobic Digestion System for Bioenergy Production and Waste Management

On a multi-fractional model for biogas production for a cellulose-based substrate

Application of anaerobic digestion model No. 1 for simulating fermentation of maize silage, pig manure, cattle manure and digestate in the full-scale biogas plant