Abstract:Carbohydrate esters are non-ionic biodegradable surfactant that possessed wide range of hydrophilic-lipophilic balance (HLB) value. It has been extensively produced via conventional chemical esterification route. This resulted in a number of disadvantages e.g. environmental pollution and personnel safety. Enzyme catalyzed production of carbohydrate esters is viewed as an alternative route to chemical synthesis. Lipase belongs to hydrolase, a green and safer family that has been widely utilized in synthetic steps. Conventionally, lipase is known for its capability to hydrolyze triacylglyceride in an aqueous system. On the contrary, lipase exhibits esterase activities in the microaqueous system.In this study, lipase-catalyzed esterification reaction and properties of synthesized carbohydrate esters were investigated. Methyl α-D-glucopyranoside as acyl group acceptor and different carbon atom chain length of carboxylic acids as the acyl group donor (hexadecanoic acid, tetradecanoic acid and dodecanoic acid) were applied in the esterification. Full factorial experimental design was used to study the effects of different process parameters toward lipase-catalyzed esterification. Methyl 6-Ohexadecanoyl- α-D-glucopyranoside was used as the model carbohydrate ester in the study. It was found via statistical analysis (α = 0.05) that process parameters viz.substrates mol ratio (acyl acceptor: acyl donor), enzyme loading (g), quantity of 4A molecular sieve (g), reaction time (hr) and agitation speed (rpm) significantly affected the esterification and only reaction temperature (°C) did not. Melting point for the methyl 6-O-hexadecanoyl-α-D-glucopyranoside was the highest at 81 °C followed with methyl 6-O-tetradecanoyl α-D-glucopyranoside at 80 °C and the lowest was recorded by methyl 6-O-dodecanoyl-α-D-glucopyranoside at 73 °C.Methyl 6-O-hexadecanoyl-α-D-glucopyranoside, methyl 6-O-tetradecanoyl-α-Dglucopyranoside and methyl 6-O-dodecanoyl-α-D-glucopyranoside had melting enthalpy of 34.8 kJ mol-1, 48.0 kJ mol-1 and at 40.9 kJ mol-1 respectively. For the melting entropy, the values for methyl 6-O-hexadecanoyl-α-D-glucopyranoside was 0.43 kJ mol-1 °C-1, methyl 6-O-tetradecanoyl-α-D-glucopyranoside 0.60 kJ mol-1 °C-1 and methyl 6-O-dodecanoyl α-D-glucopyranoside 0.55 kJ mol-1 °C-1. Liquid crystal properties of the synthesized carbohydrate ester synthesized were evaluated via Optical Polarized Microscopy (OPM). It was found that the liquid crystal textures for monosubstituted carbohydrate ester were of smectic phase. Evaluation on the maximum water mass contained in a quarternary system (carbohydrate ester/n-butanol/nhexadecane/water) was done through a pseudoternary phase diagram. Phase diagram showed maximum 34% water contained in monophasic region of methyl 6-Otetradecanoyl- α-D-glucopyranoside and maximum of 52% water contained in a monophasic methyl-6-O-dodecanoyl-α-D-glucopyranoside. For methyl-6-Ododecanoyl- α-D-glucopyranoside, its concentration at aggregation was 5.2 x 10-4 mM, with minimum air/ water surface tension of 26 mN m-1. Gibbs energy of micellization was calculated at -50 kJ mol-1. Maximum adsorption density of methyl 6-O-dodecanoyl- α-D-glucopyranoside was determined at 4 x 10-6 mol m-2 while its mimimum area per surfactant molecule at air/ water surface was 47 A2.

Theoretical and Kinetic Analysis of the Esterification of Undecylenic Acid with Glycerol

Kinetics and Modeling of Melt Polycondensation for Synthesis of Poly[(butylene Succinate)‐co‐(butylene Terephthalate)], 1 – Esterification

Structural Analysis of Partial and Total Esters of Glycerol Undecenoate and Diglycerol Undecenoate

Kinetics of glycerol esterification reaction

Complete Kinetic Model for Esterification Reaction of Lauric Acid with Glycerol to Synthesize Glycerol Monolaurate

Selective Synthesis of Diglycerol Monoacetals Via Catalyst-Transfer in Biphasic System and Assessment of Their Surfactant Properties

Reaction Kinetics of the Catalytic Esterification of Citric Acid with Ethanol

Glycerol esters from the reaction of glycerol with dicarboxylic acid esters

Catalytic amidation of natural and synthetic polyol esters with sulfonamides

Kinetics and Mechanism of the Uncatalyzed Esterification of Acid-Rich Oil with Glycerol

Kinetics and modeling of fatty acids esterification on acid exchange resins

Theoretical Study of General Base-Catalyzed Hydrolysis of Aryl Esters and Implications for Enzymatic Reactions

Low-Temperature Esterification to Produce Oleic Acid-Based Wax Esters Catalyzed by 4-Dodecylbenzenesulfonic Acid

Homogeneous catalytic esterification of glycerol with cinnamic and methoxycinnamic acids to cinnamate glycerides in solventless medium: Kinetic modeling

Kinetics Study of the Esterification Reaction of Diethylene Glycol Monobutyl Ether with Acetic Acid Catalyzed by Heteropolyanion-Based Ionic Liquids

A more efficient synthesis and properties of saturated and unsaturated starch esters

Candida antartica lipase-catalyzed esterification for efficient partial acylglycerol synthesis in solvent-free system: Substrate selectivity, molecular modelling and optimization

Enzymatic Selective Synthesis of 1,3-DAG Based on Deep Eutectic Solvent Acting As Substrate and Solvent

Lipase catalysed esterification of methyl glucopyranoside with selected aliphatic carboxylic acids : investigation on reaction parameters and surfactant properties / Maryam Farhana binti Kamel Ariffin

Influence of Sodium Dodecyl Sulfate Presence on Esterification of Propylene Glycol with Lauric Acid