Abstract:Carbohydrate esters are non-ionic biodegradable surfactant that possessed wide range of hydrophilic-lipophilic balance (HLB) value. It has been extensively produced via conventional chemical esterification route. This resulted in a number of disadvantages e.g. environmental pollution and personnel safety. Enzyme catalyzed production of carbohydrate esters is viewed as an alternative route to chemical synthesis. Lipase belongs to hydrolase, a green and safer family that has been widely utilized in synthetic steps. Conventionally, lipase is known for its capability to hydrolyze triacylglyceride in an aqueous system. On the contrary, lipase exhibits esterase activities in the microaqueous system.In this study, lipase-catalyzed esterification reaction and properties of synthesized carbohydrate esters were investigated. Methyl α-D-glucopyranoside as acyl group acceptor and different carbon atom chain length of carboxylic acids as the acyl group donor (hexadecanoic acid, tetradecanoic acid and dodecanoic acid) were applied in the esterification. Full factorial experimental design was used to study the effects of different process parameters toward lipase-catalyzed esterification. Methyl 6-Ohexadecanoyl- α-D-glucopyranoside was used as the model carbohydrate ester in the study. It was found via statistical analysis (α = 0.05) that process parameters viz.substrates mol ratio (acyl acceptor: acyl donor), enzyme loading (g), quantity of 4A molecular sieve (g), reaction time (hr) and agitation speed (rpm) significantly affected the esterification and only reaction temperature (°C) did not. Melting point for the methyl 6-O-hexadecanoyl-α-D-glucopyranoside was the highest at 81 °C followed with methyl 6-O-tetradecanoyl α-D-glucopyranoside at 80 °C and the lowest was recorded by methyl 6-O-dodecanoyl-α-D-glucopyranoside at 73 °C.Methyl 6-O-hexadecanoyl-α-D-glucopyranoside, methyl 6-O-tetradecanoyl-α-Dglucopyranoside and methyl 6-O-dodecanoyl-α-D-glucopyranoside had melting enthalpy of 34.8 kJ mol-1, 48.0 kJ mol-1 and at 40.9 kJ mol-1 respectively. For the melting entropy, the values for methyl 6-O-hexadecanoyl-α-D-glucopyranoside was 0.43 kJ mol-1 °C-1, methyl 6-O-tetradecanoyl-α-D-glucopyranoside 0.60 kJ mol-1 °C-1 and methyl 6-O-dodecanoyl α-D-glucopyranoside 0.55 kJ mol-1 °C-1. Liquid crystal properties of the synthesized carbohydrate ester synthesized were evaluated via Optical Polarized Microscopy (OPM). It was found that the liquid crystal textures for monosubstituted carbohydrate ester were of smectic phase. Evaluation on the maximum water mass contained in a quarternary system (carbohydrate ester/n-butanol/nhexadecane/water) was done through a pseudoternary phase diagram. Phase diagram showed maximum 34% water contained in monophasic region of methyl 6-Otetradecanoyl- α-D-glucopyranoside and maximum of 52% water contained in a monophasic methyl-6-O-dodecanoyl-α-D-glucopyranoside. For methyl-6-Ododecanoyl- α-D-glucopyranoside, its concentration at aggregation was 5.2 x 10-4 mM, with minimum air/ water surface tension of 26 mN m-1. Gibbs energy of micellization was calculated at -50 kJ mol-1. Maximum adsorption density of methyl 6-O-dodecanoyl- α-D-glucopyranoside was determined at 4 x 10-6 mol m-2 while its mimimum area per surfactant molecule at air/ water surface was 47 A2.

Glycerol esters from the reaction of glycerol with dicarboxylic acid esters

Biocatalytic synthesis of ultra-long-chain fatty acid sugar alcohol monoesters

Comparative study of surface-active properties and antimicrobial activities of disaccharide monoesters.

Lipase catalysed esterification of methyl glucopyranoside with selected aliphatic carboxylic acids : investigation on reaction parameters and surfactant properties / Maryam Farhana binti Kamel Ariffin

Preparation and surfactant properties of diglycerol esters of fatty acids

Structural Analysis of Partial and Total Esters of Glycerol Undecenoate and Diglycerol Undecenoate

Selective Synthesis of Diglycerol Monoacetals Via Catalyst-Transfer in Biphasic System and Assessment of Their Surfactant Properties

Synthesis and Property of Polyglycerol Ester

Production and Emulsifying Effect of Polyglycerol and Fatty Acid Esters with Varying Degrees of Esterification

Utilization of Biodiesel and Glycerol for the Synthesis of Epoxidized Acyl Glycerides and Its Application As a Plasticizer

Catalytic Hydroxyethylation of Phenols with Renewable Ethylene Glycol Diester As an Alternative to Ethylene Oxide

Synthesis and Properties of Alkanolamide Polyglycerolethers

Characterization and Surface Active Properties of Aliphatic Glycerol Acetal Disodium Sulfosuccinates

Theoretical and Kinetic Analysis of the Esterification of Undecylenic Acid with Glycerol

Ethoxylated glycerol and propylene glycol glycoside palmitates from lactose

Enzymatic Synthesis of Glucose-Based Fatty Acid Esters in Bisolvent Systems Containing Ionic Liquids or Deep Eutectic Solvents

Synthesis and Characterization of N,N-Disubstituted Glycine Tetraacetyl Glucosyl Esters

Enzymatic Synthesis of Decanoic Acid Monoglycerides

Colloid, interface, and foam properties of water-soluble polyglycerol esters solutions

New Highly Co2-Philic Diglycolic Acid Esters: Synthesis and Solubility in Supercritical Carbon Dioxide