Abstract:Monoethanolamine (MEA) based CO2 capture in coal-fired power plants would consume a huge amount of the steam bleed from the steam turbines for the solvent regeneration. The unmatched steam bleed parameters for the solvent regeneration, as well as the huge amount of the process waste heat within the CO2 capture process, inevitably bringing about a significant efficiency penalty. In this study, a novel de-carbonization supercritical coal-fired power plant, which encompasses a supplementary steam turbine (SST), process heat recovery and a modified boiler heating exchangers configuration was proposed. In the proposed system, the steam bleeds for the reboiler and part of the regenerative heaters are coming from the SST, which is located in the upstream of the reheater (steam side), instead of the high and intermediate-pressure turbines (IPT), making the parameters of the steam bleed more matched with the solvent regeneration and feed water heating. In addition, part of the process heat within the CO2 capture/compression unit was efficiently recovered and beneficially used to heat the ambient air before its entering the air pre-heater. The saved flue gas can then be used to heat the feed/condensed water in the low-temperature economizer (LTE), saving part of the steam bleed from the turbines. The configuration of the superheaters/reheaters, as well as the air preheaters were also modified. The mass and energy balance as well as the system thermodynamic performance were determined by the developed models and process simulation. The economic performance of the proposed system was assessed by the cost of electricity (COE) and the cost of CO2 avoided (COA). Finally, the off-design performance of the proposed system was determined. Results showed that the energy efficiency penalty of the proposed system could decrease by 3.86%-points as compared to the reference system. The COE and COA of the proposed system without considering the CO2 transportation and storage cost were $86.11/MWh and $36.92/ton CO2, respectively, both less than those of the reference plant. The off-design operation analysis indicated that the proposed plant also featured a thermodynamics superiority in a wide range of power load variation.

Process simulation and techno-economic analysis of CO 2 capture by coupling calcium looping with concentrated solar power in coal-fired power plant

Thermodynamic Analysis of 350 MWe Coal Power Plant Based on Calcium Looping Gasification with Combined Cycle

Indirect integration of thermochemical energy storage with the recompression supercritical CO2 Brayton cycle

Technical and Economic Feasibility Evaluation of Calcium Looping with No CO2 Recirculation

Performance enhancement of a solar-assisted pulverized coal power system by integrating a supercritical CO 2 cycle

A Calcium Looping System Powered by Renewable Electricity for Long-Term Thermochemical Energy Storage, Residential Heat Supply and Carbon Capture

Techno-Economic Evaluation on Solar-Assisted Post-Combustion CO2 Capture in Hollow Fiber Membrane Contactors

Study on heat integration of supercritical coal-fired power plant with post-combustion CO2 capture process through process simulation

Advanced power cycles for coal-fired power plants based on calcium looping combustion: A techno-economic feasibility assessment

Dynamic Simulation Study On A Coal-Fired Power Plant Aided With Low-Temperature Solar Energy

A novel solar-aided lignite-fired power generation system with calcium looping CO 2 capture, lignite pre-drying and feedwater preheating

Pinch combined with exergy analysis for heat exchange network and techno-economic evaluation of coal chemical looping combustion power plant with CO<sub>2</sub> capture

Techno-economic Study of Carbon Capture from Coal-fired Power Plant Using MEA Assisted by Solar Organic Rankine Cycle for Power Generation

Integration design and control strategy of sCO 2 Brayton cycle for concentrated solar power system

Proposal and thermodynamic investigation of pressurized calcium looping integrated with chemical looping combustion for tail-end CO 2 capture in a retrofitted natural gas combined cycle power plant

Capture of CO 2 from coal using chemical-looping combustion: Process simulation

Operational Flexibility and Thermodynamic Performances of a Combined Heat and Power Plant Integrated with Carbon Capture System

An integrated de-carbonization supercritical coal-fired power plant incorporating a supplementary steam turbine, process heat recovery and a modified boiler structure

Analysis of integrated CO 2 capture and utilization via calcium-looping in-situ dry reforming of methane and Fischer-Tropsch for synthetic fuels production

Performance assessment and system optimization on supercritical CO 2 double-path recompression coal-fired combined heat and power plants with MEA-based post-combustion CO 2 capture

Process and Integration Optimization of Post-Combustion CO2 Capture System in a Coal Power Plant