Abstract:In this article, the airfoil comprising a cross flow fan has been studied at various boundary conditions by experiment and numerical solution. The airfoil generates high lift at low forward speeds and shows excellent potential for short take off and landing and vertical take off and landing. According to the experiments, lift and pitching moment coefficients of the airfoil increase and its drag coefficient reduces with the fan rotational velocity. The pitching moment coefficient enhancement demonstrates that the aircraft is more stable at higher rotational speeds. Experiments showed that the aerodynamic coefficients decrease with the free stream Reynolds number. Flow field over the airfoil has been studied by the computational fluid dynamics technique and compared with the experimental data. Numerical solution was in good agreement with the experiments. Solution showed that skin friction coefficient on the airfoil bottom wall is not sensitive to the rotational velocity, but on the upper surface, especially inside the casing, it is deeply influenced by the fan speed, while it increases with the Reynolds number on the both surfaces. According to the numerical solution, the static pressure difference between the airfoil surfaces increases with rotational velocity demonstrating higher lift coefficients at higher fan speeds, and also increases with the Reynolds number that is equivalent to the enhancement of the aerodynamic forces as shown by the experiments. Because of a sharp edge a sudden jump was observed in the pressure distribution on the airfoil upper wall. By replacing this sharp edge with a smooth and round one this pressure jump reduced significantly and pressure distribution on the modified surface became smoother and its extremal value diminished considerably. The streamlines on the upper surface were closer than those on the bottom surface indicating higher pressure on the airfoil bottom wall. They became closer on the airfoil upper surface when fan speed increased. In addition, velocity gradient on the airfoil surfaces increased with the Reynolds number that is tantamount to a higher skin friction coefficient. Discrepancies between numerical and experimental data can be attributed to measurement uncertainty in the experiments and convergence precision in the numerical solution, two-dimensional solution in the computational fluid dynamics and three dimensionality of the flow at the wing tips in reality.

Fan Flow Field in an Installed Variable Pitch Fan Operating in Reverse Thrust for a Range of Aircraft Landing Speeds

Reverse Thrust Aerodynamics of Variable Pitch Fans

Numerical simulation of internal flow in forward-curved centrifugal fan

Performance Impact of Uncertain Variations of Inlet Flow for Axial Compressor Blades

Study of the Aerodynamic Characteristics on the Computed Flowfield During Thrust Reversers Operation

On the Performance of Variable-Geometry Ducted E-Fans

Flow physics and loss mechanisms of tip leakage flow in variable-blade-pitch-angle ducted fans

Numerical investigation of the aerodynamic performance and loss mechanism in a low bypass ratio variable cycle engine fan

CFD Study of an Annular-Ducted Fan Lift System for VTOL Aircraft

Experimental and numerical study of an airfoil in combination with a cross flow fan

Fan Root Aerodynamics for Large Bypass Gas Turbine Engines: Influence on the Engine Performance and 3D Design

A kind of new concept - Supersonic incoming-flow fan

Physics of Reverse Flow on Rotors at High Advance Ratios

3-D viscous numerical investigation on flow field of a transonic axial-flow fan rotor

Investigation of varying tip clearance gap and operating conditions on the fulfilment of low-speed axial flow fan

The matching characteristics and flow mechanisms of partial-height booster rotor and fan rotor for a high-throughflow fan

Longitudinal Aerodynamic Characteristics of Ducted Fan Propelled Fixed-Wing VTOL Aircraft Hovering in Ground Effect

Mid-Span Stall Inception in Low-Pressure-Ratio Transonic Fans

An Aerodynamic Analysis of a Robustly Redesigned Modern Aero-Engine Fan

A New Blade Profile for Bidirectional Flow Properly Applicable to a Two-stage Jet Fan

Effect of Gurney Flap on Performance and Aeroacoustics of Variable-Pitch Axial Fans