Abstract:p-Type hydrogenated silicon carbide (p-SiC:H) films were prepared using plasma-enhanced chemical vapor deposition by systematically incorporating carbon into nanocrystalline silicon networks. The carbon content of the films was varied by adjusting the methane/silane (CH4/SiH4; R-c) ratio. The chemical bonding, micro structural, and electro-optical properties of the films were investigated in detail. With increasing R-c,R-, the silicon carbon bond density in the films increased gradually and the overall microstructure became amorphous. Through sophisticated control of the carbon content of the films during high hydrogen dilution deposition, p-type hydrogenated nanocrystalline SiC:H (p-nc-SiC:H) films with nanometer-scale Si crystallites embedded in an amorphous SiC:H matrix were obtained. The p-nc-SiC:H films had wide bandgaps larger than 2 eV and reduced parasitic light absorption at wavelengths below 550 nm. When using wide-bandgap p-nc-SiC:H films with superior electro-optical properties as window layers in n-i-p flexible and p-i-n semi-transparent nc-Si:H solar cells, in place of conventional p-nc-Si:H layers with narrow bandgaps, enhanced cell performance was achieved because of both high open circuit voltage (V-oc) and high quantum efficiency values at short wavelengths of 350-550 nm. The conversion efficiencies of the flexible nc-Si:H solar cells increased from 6.37% (V-oc = 0.41 V, J(sc) = 22.81 mA/cm(2), and FF = 68.10%, where Jsc is the short-circuit current density and FF is the fill factor, respectively) to 7.89% (Voc = 0.51 V, J(sc) = 24.04 mA/cm(2), and FF = 64.37%). A further increase in the conversion efficiency to 9.18% was obtained by inserting a very thin, highly-doped p-nc-SiC:H buffer layer between a low-doped p-nc-SiC:H window layer and an indium tin oxide front contact. A significant increase in the conversion efficiency from 3.66% (V-oc = 0.42 V, J(sc) = 14.83 mA/cm(2), and FF = 58.69%) to 4.33% (V-oc = 0.45 V, J(sc) = 17.74 mA/cm(2), and FF = 54.18%) was achieved with the semi-transparent nc-Si:H solar cell, with an average optical transmittance of 17.29% in the visible wavelength region of 500-800 nm.

Fabrication of Si heterojunction solar cells using P-doped Si nanocrystals embedded in SiNx films as emitters

Hybrid heterojunction and photoelectrochemistry solar cell based on silicon nanowires and double-walled carbon nanotubes.

Improved Device Performance of Si-based Heterojunction Solar Cells by Using Phosphorus Doped Si Nanocrystals Embedded in SiC Host Matrix

Improved Nanocrystal Formation, Quantum Confinement and Carrier Transport Properties of Doped Si Quantum Dot Superlattices for Third Generation Photovoltaics

Silicon-nanocrystal-incorporated Ternary Hybrid Solar Cells

Fabrication and Optimization of Single-Junction Nc-Si:H N–i–p Solar Cells Using Si:H Phase Diagram Concepts Developed by Real Time Spectroscopic Ellipsometry

Application of Silicon Nanocrystals in Solar Cells

Silicon Nanocrystal Conjugated Polymer Hybrid Solar Cells with Improved Performance

Microstructure and Photoelectric Properties of P-Doped Silicon-Rich Sinx Film As an N-Type Layer for Pin-Type Amorphous Silicon Thin Film Solar Cells

Preparation of Nano-Patterned Si Structures for Hetero-Junction Solar Cells

Silicon nanocrystals synthesized using very high frequency non-thermal plasma and their application in photovoltaics

Effect of Si Nanoparticles on Electronic Transport Mechanisms in P-doped Silicon-Rich Silicon Nitride/c-Si Heterojunction Devices

Enhanced Device Performance of Si Nanowires/si Nanocrystals Heterojunction Solar Cells with Ultrathin Al2O3 Passivation

Enhanced Solar Energy Conversion in Au-doped, Single-Wall Carbon Nanotube-Si Heterojunction Cells

Nanocrystalline‐silicon hole contact layers enabling efficiency improvement of silicon heterojunction solar cells: Impact of nanostructure evolution on solar cell performance

Light Harvesting and Enhanced Performance of Si Quantum Dot/Si Nanowire Heterojunction Solar Cells

Using phosphorus doped hydrogenated silicon oxycarbide film as a window layer on the light entrance side of silicon heterojunction solar cells: The role of phase separation on electron transport

Development of high conducting phosphorous doped nanocrystalline thin silicon films for silicon heterojunction solar cells application

Wide-bandgap Nanocrystalline Silicon-Carbon Alloys for Photovoltaic Applications

Improved Photovoltaic Performance of MEH‐PPV/PCBM Solar Cells Via Incorporation of Si Nanocrystals

Antireflection Properties and Solar Cell Application of Silicon Nanostructures