Abstract:As a key factor affecting thermal behaviors of liquid hydrogen (LH2) tanks, heat leakage plays an important role in accurate prediction of pressure build-up for safe storage and transportation of LH2. Uniform heat flux between vapor and liquid in LH2 tanks is widely adopted as thermal boundary condition in predicting pressure build-up process. However, a distribution of heat flux between vapor and liquid was observed during the self -pressurization process in the experimental test. In light of this, an analytically theoret-ical model of revealing the energy exchange process among the vapor, liquid and inner wall is proposed to investigate the heat leakage distribution ratio (HDR) between vapor and liquid in LH2 tanks. The feasibility of the model is validated by the experimental results from NASA. In the whole self-pressurization process of 25,000 s, HDR reduces from 0.803 to 0.235 under a liquid fill ratio of 90% and a total heat leakage of 71.3 W. The results show that the existence of inner wall and different thermal properties between the vapor and liquid make the heat leakage flux non-uniformly distributed into the vapor and liquid. And the geometric structure of tank, thermal properties and initial states of the vapor and liquid have a significant effect on HDR. When coupling the model with thermal multi-zone model, the relative error in pressure prediction is reduced by 61.8% against experimental results. Benefiting from the coupled model, the relative error in pressure prediction caused by the uniform heat flux boundary condition reduces from 90.16% to 8.15%. The present work establishes theoretical foundation on analyzing heat leakage distribution between the vapor and liquid for LH2 tanks, and provides useful guidance on modifying boundary conditions in accurately predicting thermal behaviors of LH2 tanks.(c) 2023 Hydrogen Energy Publications LLC. Published by Elsevier Ltd. All rights reserved.

Applicability of Ideal Gas Law in the Air-bearing of Hard Drives

Equation Of State And Transport Properties Of Warm Dense Helium Via Quantum Molecular Dynamics Simulations

A practical density equation for saturated vapor of helium-3 from 0.01 K to the critical point

THE INFLUENCE OF NON-IDEAL EFFECTS OF ACTUATING MEDIUM ON THE PERFORMANCE OF A PLASTIC CRYOCOOLER

Investigation on Liquid Density Data at the Bubble Point and Equations for the Refrigerant Hfc-404a over A Wide Temperature Range

Influence of the rarefied effect on gas lubrication performances in the hard disk drive

Investigation Of Helium And Nitrogen Mixtures In A Pulse Tube Refrigerator

Numerical simulation of the dynamic characteristics of the ultra-thin gas flow at the head/disk interface of hard disk drives

Squeeze Film Effect and Hydrodynamics for Ultra-thin Gas Film Lubrication at the Head/Disk Interface in Hard Disk Drives

Study on real-gas equations of high pressure hydrogen

Appropriate Formulations for Velocity and Pressure Calculations at Gas-liquid Interface with Collocated Variable Arrangement

Theoretical investigation on heat leakage distribution between vapor and liquid in liquid hydrogen tanks

Analysis on Dynamic Characteristics of Air Bearing over Bit Pattern Media in Hard Disk Drives

On the equation of state of the hard disk system: the fluid-hexatic phase transition

Examination of Appropriate Formulations for Velocity and Pressure Calculation Methods at Interfacial Region on Collocated Physical Variables' Distribution

High-order Virial Coefficients and Equation of State for Hard Sphere and Hard Disk Systems

Influence of Disk Surface Bulge and Hard Disk Operating Conditions on Hard Disk Gas Film Heat Transfer

Viscosity Correlations of Normal Gases at Normal Pressures and Several HFC Refrigerants Using the Corresponding States Theory

Ultrathin Gas Film Lubrication Theory at Nanoscale

Lubricant Film Flow and Depletion Characteristics at Head/disk Storage Interface

Performance Analysis of Externally Pressurized Gas Journal Bearing Lubricated with Vapor of R134a in Centrifugal Compressor