A note on the Moody diagram

Paulo R. de Souza Mendes

2023-08-21

Abstract:In this work we propose an alternate scaling for the head loss in the steady flow of Newtonian fluids through tubes. The characteristics of the proposed scaling render more clear the role of inertia in this flow and ensure that the trends of the relationship between dimensionless quantities are the same ones observed in the dimensional problem.

Fluid Dynamics

What problem does this paper attempt to address?

Completing Moody's friction diagram in the turbulent transitional regime

Rory T. Cerbus,Tom Mullin

2024-10-18

Abstract:The Moody diagram, a plot of friction factor versus flow rate, is a well-known engineering tool for estimating head loss in pipe flows. It comprises well-defined relationships between friction factor and flow rate over the majority of parameter space, but there is a gap in the transitional regime between laminar and turbulent flows. It is often left hatched because in this parameter range the friction is deemed indefinite, which Moody remarked could at least partially be due to the different initial conditions used to establish the flow. Here we investigate this issue and seek a systematic dependence for friction in the transitional regime. The novel method we use is to approach the transitional regime from above by reducing the flow speed from a turbulent flow state. We find that in different pipe flow setups, both driven by gravity, a single curve corresponding to a maximum density of the transitional flow structures is found. We test the generality of this result using an alternative method to drive the flow through the pipe, using a mass displacement device. Our investigation of the flow driven by a syringe produces yet a different curve, indicating that the method of driving the flow has a significant impact on both the final states and the paths to them in the transitional regime.

Fluid Dynamics
Major and minor head losses in a hydraulic flow circuit: experimental measurements and a Moody’s diagram application

Aline Amaral Madeira

DOI: https://doi.org/10.26850/1678-4618eqj.v45.3.2020.p47-56

2020-07-01

Eclética Química Journal

Abstract:Domestic and industrial hydraulic drainage networks have gradually become more complicated because of the cities’ rapid expansion. In surcharged hydraulic systems, the head losses may become rather significant, and should not be neglected because could result in several problems. This work presents an investigation about major and minor head losses in a hydraulic flow circuit, simulating the water transport in a drainage network at room temperature (298.15 K) under atmospheric pressure (101,325 Pa). The losses produced by the fluid viscous effect through the one used cast-iron rectilinear pipe (RP-11) and the localized losses generated by two flow appurtenances, one fully open ball valve (BV-1) and one module of forty-four 90o elbows (90E-8) were experimentally measured. Experimental data generated head-loss curves and their well fitted to potential regressions, displaying correlation coefficients (R2) of 0.9792, 0.9924, and 0.9820 for BV-1, 90E-8, and RP-11, respectively. Head loss experimental equations and local loss coefficients through BV-1 and 90E-8 were determined successfully. The Moody’s diagram application proved to be a quite appropriate tool for an approximate estimation of Darcy-Weisbach friction factor. A good approximation between friction factor values obtained via experimental measurements and the Moody’s diagram was observed with mean absolute deviate of 0.0136.
A hydrodynamic model of capillary flow in an axially symmetric tube with a non-slowly-varying cross section and a boundary slip

Masao Iwamatsu

DOI: https://doi.org/10.1063/5.0203460

2024-05-05

Abstract:The capillary flow of a Newtonian and incompressible fluid in an axially symmetric horizontal tube with a non-slowly-varying cross section and a boundary slip is considered theoretically under the assumption that the Reynolds number is small enough for the Stokes approximation to be valid. Combining the Stokes equation with the hydrodynamic model assuming the Hagen-Poiseulle flow, a general formula for the capillary flow in a non-slowly-varying tube is derived. Using the newly derived formula, the capillary imbibition and the time evolution of meniscus in tubes with non-uniform cross sections such as a conical tube, a power-law-shaped diverging tube, and a power-law-shaped converging tube are reconsidered. The perturbation parameters and the corrections due to the non-slowly-varying effects are elucidated and the new scaling formulas for the time evolution of the meniscus of these specific examples are derived. Our study could be useful for understanding various natural fluidic systems and for designing functional fluidic devices such as a diode and a switch.

Fluid Dynamics
Viscoelastic flow in rotating curved pipes

yitung chen,huajun chen,jinsuo zhang,benzhao zhang

DOI: https://doi.org/10.1063/1.2336454

IF: 4.6

2006-01-01

Physics of Fluids

Abstract:Fully developed viscoelastic flows in rotating curved pipes with circular cross section are investigated theoretically and numerically employing the Oldroyd-B fluid model. Based on Dean's approximation, a perturbation solution up to the secondary order is obtained. The governing equations are also solved numerically by the finite volume method. The theoretical and numerical solutions agree with each other very well. The results indicate that the rotation, as well as the curvature and elasticity, plays an important role in affecting the friction factor, the secondary flow pattern and intensity. The co-rotation enhances effects of curvature and elasticity on the secondary flow. For the counter-rotation, there is a critical rotational number R-Omega', which can make the effect of rotation counteract the effect of curvature and elasticity. Complicated flow behaviors are found at this value. For the relative creeping flow, R-Omega' can be estimated according to the expression R-Omega'=-4We delta. Effects of curvature and elasticity at different rotational numbers on both relative creeping flow and inertial flow are also analyzed and discussed. (c) 2006 American Institute of Physics.
Variational approach for the flow of Ree-Eyring and Casson fluids in pipes

Taha Sochi

DOI: https://doi.org/10.1142/S1793962316500070

2015-03-22

Abstract:The flow of Ree-Eyring and Casson non-Newtonian fluids is investigated using a variational principle to optimize the total stress. The variationally-obtained solutions are compared to the analytical solutions derived from the Weissenberg-Rabinowitsch-Mooney equation and the results are found to be identical within acceptable numerical errors and modeling approximations.

Fluid Dynamics
The Flow of Newtonian and power law fluids in elastic tubes

Taha Sochi

DOI: https://doi.org/10.1016/j.ijnonlinmec.2014.09.013

2014-05-16

Abstract:We derive analytical expressions for the flow of Newtonian and power law fluids in elastic circularly-symmetric tubes based on a lubrication approximation where the flow velocity profile at each cross section is assumed to have its axially-dependent characteristic shape for the given rheology and cross sectional size. Two pressure-area constitutive elastic relations for the tube elastic response are used in these derivations. We demonstrate the validity of the derived equations by observing qualitatively correct trends in general and quantitatively valid asymptotic convergence to limiting cases. The Newtonian formulae are compared to similar formulae derived previously from a one-dimensional version of the Navier-Stokes equations.

Fluid Dynamics
Further validation to the variational method to obtain flow relations for generalized Newtonian fluids

Taha Sochi

DOI: https://doi.org/10.1007/s13367-015-0012-1

2015-03-22

Abstract:We continue our investigation to the use of the variational method to derive flow relations for generalized Newtonian fluids in confined geometries. While in the previous investigations we used the straight circular tube geometry with eight fluid rheological models to demonstrate and establish the variational method, the focus here is on the plane long thin slit geometry using those eight rheological models, namely: Newtonian, power law, Ree-Eyring, Carreau, Cross, Casson, Bingham and Herschel-Bulkley. We demonstrate how the variational principle based on minimizing the total stress in the flow conduit can be used to derive analytical expressions, which are previously derived by other methods, or used in conjunction with numerical procedures to obtain numerical solutions which are virtually identical to the solutions obtained previously from well established methods of fluid dynamics. In this regard, we use the method of Weissenberg-Rabinowitsch-Mooney-Schofield (WRMS), with our adaptation from the circular pipe geometry to the long thin slit geometry, to derive analytical formulae for the eight types of fluid where these derived formulae are used for comparison and validation of the variational formulae and numerical solutions. Although some examples may be of little value, the optimization principle which the variational method is based upon has a significant theoretical value as it reveals the tendency of the flow system to assume a configuration that minimizes the total stress. Our proposal also offers a new methodology to tackle common problems in fluid dynamics and rheology.

Fluid Dynamics
Flow of Jeffrey Fluid through Narrow Tubes

Santhosh Nallapu,G. Radhakrishnamacharya

DOI: https://doi.org/10.48550/arXiv.1403.7695

2014-09-23

Abstract:The present paper deals with a two-fluid model for the flow of Jeffrey fluid in tubes of small diameters. It is assumed that the core region consists of Jeffrey fluid and Newtonian fluid in the peripheral region. Analytical expressions for velocity, effective viscosity, core hematocrit and mean hematocrit have been derived. The effects of various parameters, namely, Jeffrey parameter ({\lambda}1), tube hematocrit (H0) and tube radius (a) on effective viscosity, core hematocrit and mean hematocrit have been studied. It is found that the effective viscosity decreases as the Jeffrey parameter increases but increases with tube hematocrit and tube radius. Further, the core hematocrit decreases with Jeffrey parameter, tube hematocrit and tube radius. It is also noticed that the flow exhibits the anomalous Fahraeus-Lindquist effect.

Fluid Dynamics
Scaling description of frictionless dense suspensions under inhomogeneous flow

Bhanu Prasad Bhowmik,Christopher Ness

2023-08-16

Abstract:Predicting the rheology of dense suspensions under inhomogeneous flow is crucial in many industrial and geophysical applications, yet the conventional `$\mu(J)$' framework is limited to homogeneous conditions in which the shear rate and solids fraction are spatially invariant. To address this shortcoming, we use particle-based simulations of frictionless dense suspensions to derive new constitutive laws that unify the rheological response under both homogeneous and inhomogeneous conditions. By defining a new dimensionless number associated with particle velocity fluctuations and combining it with the viscous number, the macroscopic friction and the solids fraction, we obtain scaling relations that collapse data from homogeneous and inhomogeneous simulations. The relations allow prediction of the steady state velocity, stress and volume fraction fields using only knowledge of the applied driving force.

Soft Condensed Matter
Modeling of low Mach number unsteady turbulent pipe flows

Carmine Di Nucci,Simone Michele,Marcello Di Risio

DOI: https://doi.org/10.1007/s11012-024-01819-w

IF: 2.7

2024-05-22

Meccanica

Abstract:Under adiabatic conditions, and neglecting temperature variations due to entropy production, we present a set of Reynolds Averaged Navier–Stokes (RANS) equations for fluids of low compressibility, i.e., fluids in the liquid state. In the low Mach number limit, we specialize the RANS equations to the one-dimensional unsteady pipe flow, and we deduce the dimensionless number that plays a predominant role in the flow behavior. We reduce the system of equations to a linear damped wave equation, and use its analytical solution to investigate the propagation of large amplitude pressure waves in liquid-filled pipes (water hammer phenomenon). We test the model reliability by comparing the analytical solution of the proposed model against experimental data available in the literature.

mechanics
New Results from CLEO

D. Cinabro

DOI: https://doi.org/10.48550/arXiv.hep-ex/0009045

2000-09-21

Abstract:The latest results from the CLEO collaboration are summarized. An update on the status of the upgraded CLEO III detector is also included.

High Energy Physics - Experiment
Adaptive Hagen-Poiseuille flows on graphs

Rodrigo Almeida,Rui Dilão

DOI: https://doi.org/10.48550/arXiv.2111.15350

2021-11-21

Abstract:We derive a class of equations describing low Reynolds number steady flows of incompressible and viscous fluids in networks made of straight channels, with several sources and sinks, and adaptive conductivities. The flow is controlled by the fluxes at sources and sinks. The network is represented by a graph and the adaptive conductivities describe the transverse channel elasticities, mirroring several network structures found in physics and biology. Minimising the dissipated energy per unit time, we have found an explicit form for the adaptation equations and, asymptotically in time, a steady state tree geometry for the graph connecting sources and sinks is reached. A phase transition tuned by an order parameter for the adapted steady sate graph has been found.

Fluid Dynamics,Biological Physics
Moving tubes: the role of walls in a modified Bernoulli equation

H. S. G. Amaral,R. de Melo e Souza,R. M. Pereira

DOI: https://doi.org/10.1088/1361-6404/ad8f7b

2024-11-08

European Journal of Physics

Abstract:In this paper, standard and introductory examples of fluid dynamics are analyzed from an unusual perspective, choosing reference frames in which the tube carrying the fluid is also moving. In such frames, Bernoulli's equation is not valid, and to analyze the energy balance one must account for the work exerted by the tube's wall. This example provides a useful pedagogical bridge between fluid dynamics and mechanics courses, allowing both instructors and curious students to (i) reinforce tools such as the work-energy theorem and (ii) appreciate the special nature of the tube's rest frame, a point rarely emphasized in textbooks. In addition, it is shown how elementary arguments may be used to construct, for a class of representative examples, a frame invariant expression for the pressure difference.

physics, multidisciplinary,education, scientific disciplines
The rheological kolmogorov scales of viscoelastic Oldroyd-B fluids

H.R. Anbarlooei,F. Ramos,G.E.O. Celis,C. Mageski,D.O.A. Cruz

DOI: https://doi.org/10.1016/j.jnnfm.2024.105257

IF: 3.112

2024-05-14

Journal of Non-Newtonian Fluid Mechanics

Abstract:This article introduces a method to determine the Kolmogorov rheological scales for turbulent flow in Viscoelastic Oldroyd-B fluids. The findings reveal a noteworthy characteristic wherein the Kolmogorov rheological length is consistently smaller than that observed in Newtonian cases. Moreover, this length diminishes with an increase in the prominence of elastic effects. Leveraging these rheological scales, a detailed friction equation for turbulent flow in Oldroyd-B fluids is derived. The resultant friction relationship exhibits a high degree of agreement with existing theories. Notably, it delineates the Maximum Drag Reduction (MDR) scenario for the studied case ( β =0.9). Additionally, the investigation delves into the onset of drag reduction effects, shedding light on the transitional phases in viscoelastic fluid flows.

mechanics
Alternative Constitutive Relation for Momentum Transport of Extended Navier–Stokes Equations

Guo-Feng Han,Xiao-Li Liu,Jin Huang,Kumar Nawnit,Liang Sun

DOI: https://doi.org/10.1088/1674-1056/abb3e5

2020-01-01

Chinese Physics B

Abstract:The classical Navier–Stokes equation（NSE） is the fundamental partial differential equation that describes the flow of fluids, but in certain cases, like high local density and temperature gradient, it is inconsistent with the experimental results.Some extended Navier–Stokes equations with diffusion terms taken into consideration have been proposed. However,a consensus conclusion on the specific expression of the additional diffusion term has not been reached in the academic circle. The models adopt the form of the generalized Newtonian constitutive relation by substituting the convection velocity with a new term, or by using some analogy. In this study, a new constitutive relation for momentum transport and a momentum balance equation are obtained based on the molecular kinetic theory. The new constitutive relation preserves the symmetry of the deviation stress, and the momentum balance equation satisfies Galilean invariance. The results show that for Poiseuille flow in a circular micro-tube, self-diffusion in micro-flow needs considering even if the local density gradient is very low.
Scale dependence and non-isochoric effects on the thermohydrodynamics of rarefied Poiseuille flow

Shashank Ravichandir,Meheboob Alam

DOI: https://doi.org/10.1017/jfm.2024.681

IF: 3.7

2024-10-02

Journal of Fluid Mechanics

Abstract:The plane Poiseuille flow of a rarefied gas in a finite length channel, driven by an axial pressure gradient, is analysed numerically to probe (i) the role of 'dilatation' ( ) on its thermohydrodynamics as well as to clarify (ii) the possible equivalence with its well-studied 'dilatation-free' or 'isochoric' ( ) counterpart driven by a constant acceleration. Focussing on the mass flow rate , which is an invariant quantity for both pressure-driven and acceleration-driven Poiseuille flows, it is shown that while at in the acceleration-driven case, the mass flow saturates to a constant value at in the pressure-driven case due to the finite length ( ) of the channel. The latter result agrees with prior theory and recent experiments, and holds irrespective of the magnitude of the axial pressure gradient ( ). The pressure-dilatation cooling ( ) is shown to be responsible for the absence of the bimodal shape of the temperature profile in the pressure-driven Poiseuille flow. The dilatation-driven reduction of the shear viscosity and the odd signs of two normal stress differences ( and ) in the pressure-driven flow in comparison with those in its acceleration-driven counterpart are explained from the Burnett-order constitutive relations for the stress tensor. While both and appear at the Burnett order in the acceleration-driven flow, the leading term in scales as due to the non-zero dilatation in the pressure-driven Poiseuille flow which confirms that the two flows are not equivalent even at the Navier–Stokes–Fourier order . The heat-flow rate ( ) of the tangential heat flux is found to be negative (i.e. directed against the axial pressure gradient), in contrast to its positive asymptotic value (at ) in the acceleration-driven flow. Similar to the scale-dependence of the mass flow rate, is found to saturate to a constant value at in finite length channels. The double-well shape of the -profile in the near-continuum limit agrees well with predictions from a generalized Fourier law. On the whole, the dilatation-driven signatures (such as the pressure-dilatation work and the 'normal' shear-rate differences) are shown to be the progenitor for the observed differences between the two flows with regard to (i) the hydrodynamic fields, (ii) the rheology and (iii) the flow-induced heat transfer.

mechanics,physics, fluids & plasmas
A Remark on the Leray's Problem on Stationary Navier-Stokes Flows with Large Fluxes in Infinite Cylindrical Domains

Myong-Hwan Ri

DOI: https://doi.org/10.48550/arXiv.1403.1391

2014-03-06

Analysis of PDEs

Abstract:We consider Leray's problem on stationary Navier-Stokes flows with arbitrary large fluxes in an unbounded cylinder with several exits to infinity. For a stationary Navier-Stokes flow with large fluxes in the unbounded cylinder we prove that, if the difference between the pressure of the main flow and the pressure of the Poiseuille flow with the same flux in a branch of the cylinder satisfies some asymptotic boundedness condition at $|x|\rightarrow \infty$ then the flow behaves at infinity of the branch like the Poiseuille flow.
Low Reynolds number flows in a microscopic and tapered tube with a permeability

R Egashira,T Fujikawa,H Yaguchi,S Fujikawa

DOI: https://doi.org/10.1088/1873-7005/aaed57

2019-01-29

Fluid Dynamics Research

Abstract:Low Reynolds number flows in a microscopic and tapered tube with a permeability are theoretically investigated in steady conditions. A momentum equation for the main flow in the tube is derived from a set of incompressible Navier-Stokes equations for an axisymmetric flow. The second-order nonlinear ordinary differential equation on a pressure is derived using a velocity profile of the fourth-order polynomials for the main flow, in which there are nonlinear terms of both orders of Re2 and Re. Solutions obtained are classified into two types; one is a flow with a Reynolds number far less than 161, whilst another is a flow with a Reynolds number larger than the former case but smaller than 248. They are compared with an exact solution of the original nonlinear differential equation. Effects of the permeability of the tube wall and the Reynolds number of the main flow upon the pressure loss, the axial and radial components of the main flow velocity, and the resistance coefficient are clarified. Furthermore, a flow in a permeable and straight tube is investigated as a special case of the permeable and tapered tube, and it is demonstrated that an adverse pressure gradient takes place at a relatively large Reynolds number when the main flow is withdrawn through the permeable wall. As a consequence, the results obtained for the permeable and tapered tube contain flows in both the impermeable tapered tube and the impermeable straight tube, the latter of which is Hagen-Poiseuille flow, as special cases.

mechanics,physics, fluids & plasmas
The Flow of Power-Law Fluids in Axisymmetric Corrugated Tubes

Taha Sochi

DOI: https://doi.org/10.1016/j.petrol.2011.08.006

2010-06-13

Abstract:In this article we present an analytical method for deriving the relationship between the pressure drop and flow rate in laminar flow regimes, and apply it to the flow of power-law fluids through axially-symmetric corrugated tubes. The method, which is general with regards to fluid and tube shape within certain restrictions, can also be used as a foundation for numerical integration where analytical expressions are hard to obtain due to mathematical or practical complexities. Five converging-diverging geometries are used as examples to illustrate the application of this method.

Mathematical Physics,Fluid Dynamics

A note on the Moody diagram

Completing Moody's friction diagram in the turbulent transitional regime

Major and minor head losses in a hydraulic flow circuit: experimental measurements and a Moody’s diagram application

A hydrodynamic model of capillary flow in an axially symmetric tube with a non-slowly-varying cross section and a boundary slip

Viscoelastic flow in rotating curved pipes

Variational approach for the flow of Ree-Eyring and Casson fluids in pipes

The Flow of Newtonian and power law fluids in elastic tubes

Further validation to the variational method to obtain flow relations for generalized Newtonian fluids

Flow of Jeffrey Fluid through Narrow Tubes

Scaling description of frictionless dense suspensions under inhomogeneous flow

Modeling of low Mach number unsteady turbulent pipe flows

New Results from CLEO

Adaptive Hagen-Poiseuille flows on graphs

Moving tubes: the role of walls in a modified Bernoulli equation

The rheological kolmogorov scales of viscoelastic Oldroyd-B fluids

Alternative Constitutive Relation for Momentum Transport of Extended Navier–Stokes Equations

Scale dependence and non-isochoric effects on the thermohydrodynamics of rarefied Poiseuille flow

A Remark on the Leray's Problem on Stationary Navier-Stokes Flows with Large Fluxes in Infinite Cylindrical Domains

Low Reynolds number flows in a microscopic and tapered tube with a permeability

The Flow of Power-Law Fluids in Axisymmetric Corrugated Tubes