Abstract:Trucking is a key industry in Canada with around 180 000 professional drivers. As an industry it has a disproportionately high injury claim rate, particularly for back injuries. Whole-body vibration (WBV) can contribute to the onset and development of low back disorders, and is a well-documented exposure among driving professions. A widely adopted WBV mitigation measure focuses on hydraulic and/or pneumatic passive suspension systems both in the driver's seat and underneath the vehicle cab. Passive suspension 'air-ride' seats are the current industry standard but new technologies such as the electromagnetic active vibration cancelling (EAVC) seats offer potentially substantial improvements in WBV reduction. In this paper, we evaluate and compare four commonly used truck seats (three air-ride, one EAVC) for their vibration damping characteristics and WBV exposure attenuation in on- and off-road conditions. We recruited 24 professional truck drivers who drove 280 km (mixed on-road and off-road) in ore-haul trucks under four different seating conditions. Following the ISO 2631-1 WBV standard, vibration measurements were made on the cab floor and seat pad, and 8-h average weighted vibration (A(8)) and 8-h vibration dose values (VDV(8)) were calculated, as well as the Seat Effective Amplitude Transmissibility (SEAT), and daily vibration action limits (DVALs). These measures were compared between seat types, as well as road conditions. The EAVC seat gave best performance for both A(8) (0.27 m s-2) and VDV(8) (6.6 m s-1.75). The EVAC seat had the lowest SEAT tested (36.2%) and the longest DVAL. However, among the three passive air-suspension seats, two showed significantly reduced A(8) (0.43 and 0.44 m s-2) and VDV(8) (9.1 and 9.3 m s-1.75) exposures relative to the third passive air-suspension seats [A(8) (0.54 m s-2) and VDV(8) (11.1 m s-1.75)]. These differences in exposures among the three passive air-suspension seats resulted in varying DVAL times, with the worst performing seat reaching the DVAL after only 6.3 h of driving. There was also a seat by road type interaction; there were performance differences between the passive air-suspension seats on-road, but not off-road. The observed reduction of the WBV exposures measured from the EAVC seat was consistent with previous results. But we showed that there can also be substantive differences among seats that are the current industry standard. These differences were more evident on-road than off-road, which suggests that more work needs to be done to understand seat performance characteristics, and in matching the correct seat technology to the driving task. We demonstrated that WBV exposures in current industry conditions may exceed health-based exposure limits; this has policy relevance because WBV exposures are linked to prevalent and costly adverse health conditions in a working population that is ageing. Increased WBV measurement collection is recommended to ensure the anticipated exposure attenuations are achieved when seats are relied upon as an engineered control against WBV.

Seat vibration in military propeller aircraft: characterization, exposure assessment, and mitigation

Cockpit seat and pilot helmet vibration during flight operations on aircraft carriers.

Effects of vertical vibration on sitting comfort in civil aviation during the cruising flight

Vibration Effects of the Fixed-Wing Aircraft of the Army Aviation from Ecuador on the Human Body

Amplified Pilot Head Vibration and the Effects of Vibration Mitigation on Neck Muscle Strain

Development and Flight Demonstration of an Active Seat Mount System for Aircrew Whole-Body Vibration Mitigation on NRC Bell-412 Helicopter

Evaluation of the vibration transmitted to pilot’s body parts to determine the contribution of different design parameters in deficiency of available seats

Numerical Study on the Unusual Vibration Load Characteristics and Mechanisms of the Front Landing Gear Compartment

The impact of accelerometer location and frequency weightings on the prediction of pleasantness ratings for vertical whole-body vibrations on an aircraft seat bench

Transmissibility of helicopter vibration in the spines of pilots in flight

Exposure to Whole-Body Vibration in Commercial Heavy-Truck Driving in On- and Off-Road Conditions: Effect of Seat Choice

Evaluation of seatback vibration based on ISO 2631-1 (1997) standard method: The influence of vehicle seat structural resonance

Discomfort estimation for vertical whole-body vibration in the aircraft cabin considering the duration and static sitting comfort

Whole-body Vibration Exposure Intervention among Professional Bus and Truck Drivers: A Laboratory Evaluation of Seat-suspension Designs

Vibration analysis of human body under seating posture: an automobile application

The effects of whole-body vibration and head supported mass on performance and muscular demand

Evaluation of vertical and multi-axial suspension seats for reducing vertical-dominant and multi-axial whole body vibration and associated neck and low back joint torque and muscle activity

Characterisation of the human-seat coupling in response to vibration

Combined Effects of Long-Term Sitting and Whole-Body Vibration on Discomfort Onset for Vehicle Occupants

The effects of different seat suspension types on occupants' physiologic responses and task performance: implications for autonomous and conventional vehicles

The effects of whole-body vibration on human biodynamic response