Abstract:An innovative approach has been recently proposed in order to link polyhydroxyalkanoates (PHA) production with sludge minimization in municipal wastewater treatment, where (1) a sequencing batch reactor (SBR) is used for the simultaneous municipal wastewater treatment and the selection/enrichment of biomass with storage ability and (2) the acidogenic fermentation of the primary sludge is used to produce a stream rich in volatile fatty acids (VFAs) as the carbon source for the following PHA accumulation stage. The reliability of the proposed process has been evaluated at lab scale by using substrate synthetic mixtures for both stages, simulating a low-strength municipal wastewater and the effluent from primary sludge fermentation, respectively. Six SBR runs were performed under the same operating conditions, each time starting from a new activated sludge inoculum. In every SBR run, despite the low VFA content (10 % chemical oxygen demand, COD basis) of the substrate synthetic mixture, a stable feast–famine regime was established, ensuring the necessary selection/enrichment of the sludge and soluble COD removal to 89 %. A good process reproducibility was observed, as also confirmed by denaturing gradient gel electrophoresis (DGGE) analysis of the microbial community, which showed that a high similarity after SBR steady-state had been reached. The main variation factors of the storage properties among different runs were uncontrolled changes of settling properties which in turn caused variations of both sludge retention time and specific organic loading rate. In the following accumulation batch tests, the selected/enriched consortium was able to accumulate PHA with good rate (63 mg CODPHA g CODXa−1 h−1) and yield (0.23 CODPHA CODΔS−1) in spite that the feeding solution was different from the acclimation one. Even though the PHA production performance still requires optimization, the proposed process has a good potential especially if coupled to minimization of both primary sludge (by its use as the VFA source for the PHA accumulation, via previous fermentation) and excess secondary sludge (by its use as the biomass source for the PHA accumulation).

Production of polyhydroxyalkanoates (PHA) by activated sludge treating municipal wastewater: effect of pH, sludge retention time (SRT), and acetate concentration in influent

Polyhydroxyalkanoate production from fermented volatile fatty acids: effect of pH and feeding regimes.

Coupling of Polyhydroxyalkanoate Production with Volatile Fatty Acid from Food Wastes and Excess Sludge

Effect of culture history and carbon sources on polyhydroxyalkanoates production in activated sludge systems

Exploring the Limits of Polyhydroxyalkanoate Production by Municipal Activated Sludge

Process conditions affect properties and outcomes of polyhydroxyalkanoate accumulation in municipal activated sludge

Calcium enhances polyhydroxyalkanoate production and promotes selective growth of the polyhydroxyalkanoate-storing biomass in municipal activated sludge

Production of polyhydroxyalkanoates by activated sludge: Correlation with extracellular polymeric substances and characteristics of activated sludge

Sludge minimization in municipal wastewater treatment by polyhydroxyalkanoate (PHA) production

Effect of nitrogen limitation on enrichment of activated sludge for PHA production

Production of Polyhydroxyalkanoates (PHA) by Bacterial Consortium from Excess Sludge Fermentation Liquid at Laboratory and Pilot Scales

Effects of chemical oxygen demand concentration, pH and operation cycle on polyhydroxyalkanoates synthesis with waste sludge

Polyhydroxyalkanoate production using two‐stage continuous stirred tank activated sludge systems with glycerol as a carbon source

Effect of enrichment conditions of secondary feeding on the synthesis of polyhydroxyalkanoates (PHAs) by activated sludge

An assessment of the potential of a single anaerobic/aerobic/anoxic airlift bioreactor for PHA production: effect of different wastewaters

Production of Polyhydroxybutyrate by Activated Sludge Performing Enhanced Biological Phosphorus Removal.

Polyhydroxyalkanoates (PHA) Production from Fermented Thermal-Hydrolyzed Sludge by Mixed Microbial Cultures: the Link Between Phosphorus and PHA Yields

Process optimization for PHA production by activated sludge using response surface methodology

Production, downstream processing, and characterization of polyhydroxyalkanoates (PHAs) boosted by pyruvate supplement using mixed microbial culture (MMC) and organic wastewater

Investigation on PHA synthesis by activated sludge and the synthesis response to magnetic field

Polyhydroxyalkanoate (PHA) production in open mixed cultures using waste activated sludge as biomass