Abstract:This study proposed and investigated a hybrid forward osmosis - membrane distillation (FO-MD) system for sustainable water recovery from oily wastewater by employing lab-fabricated FO and MD hollow fiber membranes. Stable oil-in-water emulsions of different concentrations with small droplet sizes (<1 μm) were firstly prepared and applied as the feed solution in the FO process. Fouling was immediately observed in the FO mode and was low on the cellulose triacetate (CTA) - based thin film composite (TFC) membranes. Moreover, slight increment of fouling was observed in the first few hours and the water flux was then stabilized over 24 h. The characterizations of water flux and solute rejection in separate FO and MD processes revealed that a high water flux, good NaCl rejection, impressively high retention of oil droplets and partial permeation of acetic acid could be achieved. Finally, an integrated FO-MD system was developed to treat the oily wastewater containing petroleum, surfactant, NaCl and acetic acid at 60 °C in the batch mode. The water flux in FO undergoes three-stage decline due to fouling and reduction in osmotic driving force, but is quite stable in MD regardless of salt concentration. Oily wastewater with relatively high salinity could be effectively recovered by the FO-MD hybrid system while maintaining large water flux, at least 90% feed water recovery could be readily attained with only trace amounts of oil and salts, and the draw solution was re-generated for the next rounds of FO-MD run. Interestingly, significant amount of acetic acid was also retained in the permeate for further reuse as a chemical additive during the production of crude oil. The work has demonstrated that not only water but also organic additives in the wastewater could be effectively recovered by FO-MD systems for reuse or other utilizations.

Proof of concept: Integrated membrane distillation-forward osmosis approaches water production in a low-temperature CO2 capture

Evaluating forward osmosis performance of MEA/MDEA absorbents for water replenishment in post-combustion carbon capture

Understanding the performance of membrane for direct air capture of CO2

Membrane distillation and membrane electrolysis of coal seam gas reverse osmosis brine for clean water extraction and NaOH production

Treatment of industrial wastewater produced by desulfurization process in a coal-fired power plant via FO-MD hybrid process

Direct CO 2 mineralization using seawater reverse osmosis brine facilitated by hollow fiber membrane contactor

Dissolved Methane Rejection by Forward Osmosis Membrane to Achieve In-Situ Energy Recovery from Anaerobic Effluent

Evaluation of a novel fertilizer-drawn forward osmosis and membrane contactor hybrid system for CO 2 capture using ammonia-rich wastewater

Sustainable water recovery from oily wastewater via forward osmosis-membrane distillation (FO-MD)

Osmotically and Thermally Isolated Forward Osmosis-Membrane Distillation (FO-MD) Integrated Module

Experiment of CO_2 Separation from Flue Gases by Membrane Gas Absorption

Polyelectrolyte-Promoted Forward Osmosis-Membrane Distillation (Fo-Md) Hybrid Process for Dye Wastewater Treatment

Synergy of feed-side aeration and super slippery interface in membrane distillation for enhanced water flux and scaling mitigation

FO/MD hybrid system for real dairy wastewater recycling

Reducing the energy penalty and corrosion of carbon dioxide capture using a novel nonaqueous monoethanolamine-based biphasic solvent

Simulation and Optimization for Flue Gas CO2 Capture by Energy Efficient Water-Lean Ionic Liquid Solvent

Experimental Study of the Absorption and Regeneration Performance of Several Candidate Solvents for Post-Combustion CO2 Capture

Integration of forward osmosis and membrane distillation for sustainable wastewater reuse

Investigation on the Phase-Change Absorbent System MEA Plus Solvent A (SA) + H2O Used for the CO2 Capture from Flue Gas

An Innovative Process for Simultaneous Removal of CO2 and SO2 from Flue Gas of a Power Plant by Energy Integration

Study on seawater desalination by ammonium bicarbonate forward osmosis process