Techno-economic assessment of a hybrid forward osmosis and membrane distillation system for agricultural water recovery

Agata Zarebska-Mølgaard,Kuiling Li,Agnieszka Niedzielska,Carina Schneider,Victor Yangali-Quintanilla,Panagiotis Tsapekos,Irini Angelidaki,Jun Wang,Claus Helix-Nielsen

DOI: https://doi.org/10.1016/j.seppur.2021.120196

IF: 8.6

2022-01-01

Separation and Purification Technology

Abstract:Despite the potential of forward osmosis (FO) and membrane distillation (MD) to treat difficult waste streams, these technologies have not yet been applied on a large scale in industry. Also, economic analyses which are crucial in a commercialization of these technologies are not presently available. In this work a techno-economic study of water recovery from anaerobic digested (AD) effluents by a FO-MD hybrid process was performed. OPEX and CAPEX calculations were used to estimate a final water treatment cost based on experimental laboratory results which demonstrated that the FO-MD process can yield a high water quality for AD effluents. However the obtained water fluxes (<2 Lm−2h−1) were too low for industrial application in the present form of the FO-MD process. The energy consumption of the FO-MD system was 0.52 kWh m−3 which is 100 times lower than the electricity produced from 1 m3 of AD effluents based on methane energy yields. The cost of water produced by the FO-MD system was 1.29 $ m−3, assuming water flux of 10 Lm−2h−1 and membrane cost of 36 $ m−2. Sensitivity analysis shows that the cost of membrane module has a high influence on water cost at fluxes < 8 Lm−2h−1. Analysis shows that for the FO-MD system to be cost efficient, the water flux must exceed 14 Lm−2h−1. Thus our techno-economic assessment shows directions where the technology should be improved in order to be technically feasible and industrially applicable.

engineering, chemical