Abstract:Terbium aluminum garnet (Tb3Al5O12, TAG) ceramics have become a promising magneto‐optical material owing to the outstanding comprehensive performance, including the magneto‐optical, thermal, and mechanical properties. Fine‐grained TAG ceramics with high optical quality and mechanical properties have attracted much attention. In this study, TAG ceramics with fine grains and high optical quality are fabricated successfully by a two‐step sintering method from co‐precipitated nano‐powders. After pre‐sintered at 1525°C in vacuum and hot isostatic pressed at 1600°C, the in‐line transmittance of TAG ceramics reaches 81.8% at 1064 nm and the average grain size is 7.1 μm. The Verdet constant of TAG ceramics is ‐179.6±4.8 rad·T−1·m−1 at 633 nm and ‐52.1±1.9 rad·T−1·m−1 at 1064 nm, higher than that of commercial Tb3Ga5O12 crystals. The thermal conductivity of TAG ceramics is determined from 25°C to 450°C and the result is 5.12 W·m−1·K−1 at 25°C and 3.61 W·m−1·K−1 at 450°C. A comparison of mechanical properties between large‐grained and fine‐grained TAG ceramics fabricated under different conditions is conducted. The fine‐grained TAG ceramics possess a bending strength of 226.3±16.4 MPa, which is 9.7% higher than that of the large‐grained ceramics. These results indicate that reducing the grain size on the premise of high optical quality helps improve the comprehensive performance of TAG ceramics. This article is protected by copyright. All rights reserved

On the Crystallization of Terbium Aluminium Garnet

Magneto‐optical, thermal, and mechanical properties of polycrystalline Tb3Al5O12 transparent ceramics

Theoretical and Experimental Studies of Electronic, Optical and Luminescent Properties for Tb-based Garnet Materials

Growth and properties of neodymium-doped terbium aluminum garnet crystal

Effect of Tb4O7 Excess on the Microstructure and Magneto-Optical Properties of TAG Transparent Ceramic

Modelling and Control of Thermal Stress in TSLAG (Tb3Sc1.95Lu0.05Al3O12) Magneto-Optical Crystals Grown by Czochralski Method

Crystal Growth, Defects, Mechanical, Thermal and Optical Properties of Tb 3 Sc 2 Al 3 O 12 Magneto-Optical Crystal

Wide Concentration Range of Tb3+ Doping Influence on Scintillation Properties of (Ce, Tb, Gd)3Ga2Al3O12 Crystals Grown by the Optical Floating Zone Method

Features of synthesis of TbCr$_3$(BO$_3$)$_4$ single crystals by solution-melt method

The Crystallization Behavior of Dy3 +/tb3 + Doped Aluminoborosilicate Glasses

Sintering parameter optimization of Tb 3 Al 5 O 12 magneto‐optical ceramics by vacuum sintering and HIP post‐treatment

Crystallographic and Magnetic Properties of a TB 3 (fe,cr) 29 Single Crystal

Optical Properties, Magnetooptical Properties and Terahertz Time-Domain Spectrum of Tb3Sc2Al3O12 Crystals Grown by Optical Floating Zone Methods

Growth, Crystalline Quality and Transition Variation of Ternary Pb(In1/2nb1/2)O-3-Pb(Mg1/3nb2/3)O-3-Pbtio3 Ferroelectric Crystals

The Influence of Gallium on Magnetocaloric Effect in Gd60tb40 Alloys

Super-Necking Crystal Growth and Structural and Magnetic Properties of SrTb<sub>2</sub>O<sub>4</sub> Single Crystals

Super-Necking Crystal Growth and Structural and Magnetic Properties of SrTb$_2$O$_4$ Single Crystals

Crystallization behavior of amorphous phase in the Ti-Ni-Ta surface alloy synthesized on TiNi substrate by electron-beam method

Microstructure Evolution of the Phase Change Material Tisbte

TEM Study of Lanthanum Aluminate

Czochralski growth of YAP crystal doped with high Tm concentration