Abstract:This study developed an innovative method for phosphate recovery contained in wastewater using air cathode electrocoagulation (ACEC) technology. This technique has the advantage of low energy consumption since it can effectively produce the struvite precipitate without any electrical-grid energy consumption. The experiments were conducted under recirculating batch mode by varying the recirculation rate and initial pH of wastewater to investigate their effects on the ACEC reactor performance. SEM-EDS and XRD analyses were performed to examine the morphology and structure of the produced crystals. The result showed that the precipitates exhibited in the form of crystals with irregularly shaped accompanied by a sharp at the surface and composed of Mg (6.67%), P (6.78%), N (1.66%), and O (47.41%). XRD chromatogram showed that the precipitate matched the reference pattern for struvite. The recirculation rate of 2.0 mL min −1 was determined as an optimum condition with nitrogen and phosphate removal, nitrogen and phosphate removal rate, and struvite precipitation rate was 14.7% ± 1.2%, 57.1% ± 1.1%, 22.9 ± 0.9 mg L −1 h −1 , 18.6 ± 0.9 mg L −1 h −1 , and 498 mg h −1 , respectively. The recirculation rate affects the reactor performance through the magnitude of the hydraulic retention time of nutrients on the reactor and the potential electrical energy generated in the reactor. On the other hand, the reactor with initial pH 8 achieved the best performance with the nitrogen and phosphate removal of 24.6% ± 1.6% to 88.4% ± 3.8%, nitrogen and phosphate removal rate of 24.2 ± 2.1 mg L −1 h −1 and 35.3 ± 2.1 mg L −1 h −1 , respectively, and the struvite precipitation rate of 900 mg h −1 . Furthermore, when the initial pH of wastewater increased from 7 to 8, the struvite precipitation rate increased from 499 to 900 mg −1 . However, increasing the initial pH of wastewater from 8 to 9 caused a decrease in struvite precipitation rate from 900 to 656 mg h −1 . These results demonstrated that the recirculation rate and initial pH of wastewater control the process of the struvite precipitation process in ACEC technology.

The Efficiency of Phosphorus Removal of Synthetic Wastewater through Struvite Crystallization in an Aerated Fluidized Bed Reactor

Phosphorus removal and recovery from wastewater by highly efficient struvite crystallization in an improved fluidized bed reactor

Study of struvite crystallization from fertilizer industry wastewater by using fluidized bed reactor

Optimization design of aerated struvite-crystallizer for recovering phosphorus from swine manure using computational fluid dynamics

Phosphate enhance recovery from wastewater by mechanism analysis and optimization of struvite settleability in fluidized bed reactor

Impact of supersaturation ratio on phosphorus recovery from synthetic anaerobic digester supernatant through a struvite crystallization fluidized bed reactor

Nutrient Recovery From Organic-Rich Wastewater Through Struvite Precipitation using Air Cathode Electrocoagulation Technology

Development and simulation of a struvite crystallization fluidized bed reactor with enhanced external recirculation for phosphorous and ammonium recovery

New process for phosphorus removal with the combination of biological medium addition and calcium hydroxyphosphate crystallization

Phosphorus removal from wastewater through struvite crystallization in a continuous fluidized-bed reactor: An improved comprehensive model

Study on Removal of Phosphorus As Struvite from Synthetic Wastewater Using a Pilot-Scale Electrodialysis System with Magnesium Anode.

Multivariate optimization of phosphate removal and recovery from aqueous solution by struvite crystallization in a fluidized-bed reactor

Development of a fluidized bed reactor for phosphorus recovery from rubber industry wastewater through struvite formation: material selection and prototype

Removal and recovery of phosphate anion as struvite from wastewater

Determining the feasibility of phosphorus recovery as struvite from filter press centrate in a secondary wastewater treatment plant

Optimizing induced struvite crystallization in a fluidized bed reactor for low-strength ammonium wastewater treatment

Morphology and Elemental Composition of Product Obtained from Struvite Fluidized Bed Reactor

The Recovery of Phosphorus from Acidic Ultra-High Phosphorous Wastewater by the Struvite Crystallization

Recovering phosphorus as struvite from the concentrated solution produced by the alternating aerobic/anaerobic biofilm system

Effect of Upflow Velocity on the Performance of a Fluidized Bed Reactor to Remove Phosphate from Simulated Swine Wastewater

Development of phosphorus recovery reactor for enlargement of struvite crystals using seawater as the magnesium source.