Abstract:An excessive discharge of phosphorus from wastewater to water bodies may potentially contribute to eutrophication. On the other hand, mineral phosphorus resources will be depleted in the near future, because of difficulty to automatically recycle from water to land, unlike nitrogen. A new process for nutrients removal coupled with phosphorus recovery was proposed in this study by combining biological nutrients removal (BNR) with induced crystallization (IC), BNR-IC for short later, differently from conventional phosphorus recovery process. Our results showed that the BNR-IC system can maintain not only high and stable carbon, nitrogen and phosphorus removal efficiencies, all presenting above 90%, but also good phosphorus recovery performance from synthetic domestic wastewater, displaying about 70.2% of phosphorus recovery rate. When the COD, TN, NH4–N and P concentrations of 250 mg L−1, 42 mg L−1, 40 mg L−1, and 10 mg L−1, respectively were given in the influent, a stable removal efficiencies of 92.5% COD, 78.6% TN, 85.9% NH4–N and 95.2% P were obtained for the BNR-IC process and correspondingly the COD, TN, NH4–N and P concentrations of 18.75 mg L−1, 8.99 mg L−1, 5.64 mg L−1, 0.42 mg L−1 were monitored in the effluent, meeting the Chinese National Class I (grade A) Sewage Discharge Standard. Analyses of SEM and EDS, moreover, also demonstrated that the surface of seed crystal (calcite used here) was completely covered by hydroxyl calcium phosphate (HAP) produced during the induced crystallization process to recover phosphorus. Although our study involved only a small-scale trial, the proposed BNR-IC process here may be a promising technology, and can potentially aid in improvement of the effluent quality from WWTP and in recycle of mineral phosphorus resources when applied to practice.

New process for phosphorus removal with the combination of biological medium addition and calcium hydroxyphosphate crystallization

Phosphorus removal and recovery from wastewater by highly efficient struvite crystallization in an improved fluidized bed reactor

Performance of calcium phosphates crystallization process for phosphorus removal

A new process for simultaneous nitrogen removal and phosphorus recovery using an anammox expanded bed reactor

Phosphorus Removal and Recovery from High Phosphorus Wastewater by the HAP Crystallization Process

Phosphorus Removal Using Ferric–calcium Complex As Precipitant: Parameters Optimization and Phosphorus-Recycling Potential

A Novel Fe(II)-Ca Synergistic Phosphorus Removal Process: Process Optimization and Phosphorus Recovery.

Remove and Recover Phosphorus During Anaerobic Digestion of Excess Sludge by Adding Waste Iron Scrap

Optimization of induced crystallization reaction in a novel process of nutrients removal coupled with phosphorus recovery from domestic wastewater

Hydroxyapatite crystallization-based phosphorus recovery coupling with the nitrogen removal through partial nitritation/anammox in a single reactor

Clarification of the phosphorus release mechanism for recovering phosphorus from biofilm sludge in alternating aerobic/anaerobic biofilm system

A novel calcium peroxide/attapulgite-Fe(II) process for high concentration phosphate removal and recovery: Efficiency and mechanism

Simultaneous phosphorus recovery from wastewater and sludge by a novel denitrifying phosphorus removal system

Phosphates Recovery through Hydroxyapatite Crystallization from Wastewater Using Converter Slag as a Seed Crystal

Simultaneous nitrite production and phosphorus removal by partial denitrification-hydroxyapatite (PD-HAP) coupled process from high-nitrate wastewater

Sequencing biological acidification of waste-activated sludge aiming to optimize phosphorus dissolution and recovery

A new approach to removing and recovering phosphorus from livestock wastewater using dolomite

A NOVEL PROCESS FOR NUTRIENTS REMOVAL AND PHOSPHORUS RECOVERY FROM DOMESTIC WASTEWATER BY COMBINING BNR WITH INDUCED CRYSTALLIZATION

Recovery of phosphorus resource from a new bidogical wastewater treatment process with on-site reduction of excess sludge

Biologically induced phosphorus precipitation in aerobic granular sludge process

Phosphorus recovery from pig manure: Dissolution of struvite and formation of calcium phosphate granules during anaerobic digestion with calcium addition