Abstract:As the device size continues to shrink, the gate oxygen layer in MOS devices continues to become thinner, which leads to problems such as increased leakage current in conventional Si MOS devices. SiC, an important semiconductor material used in high-power devices, is not immune to the problem of premature breakdown due to the gate oxygen layer. Based on this, this paper adopts the innovative approach of replacing the conventional SiO 2 as the gate oxygen layer with the high-k material, hafnium dioxide (HfO 2 ), and continues the in-depth study on the electrical characteristics of the gate oxygen structure. In this paper, hafnium dioxide (HfO 2 ) thin films were deposited on SiC and Si substrates using the atomic layer deposition(ALD) method. The metal-insulated semiconductor (MIS) structures with Al as the upper and lower electrodes were prepared, and the leakage currents and breakdown voltage characteristics of the MOS capacitors on the two different substrates were investigated. The leakage current density of the MOS capacitor structure with SiC substrate is 10 -11 A/cm 2 ,and the breakdown voltage is about 32 V. Based on the capacitance-voltage (C-V) measurements, the frequency dependence of the movable charge at the interface of the MOS capacitor structure is investigated. The lowest interfacial defect density (D it ) of the MOS capacitive structure with SiC substrate is only of the order of 10 10 eV -1 cm -2 , while the movable charge N eff of the oxide layer of this sample is also controlled to the order of 10 13 cm -2 . It is worth mentioning that the HfO 2 /SiC structure performs better than the HfO 2 /Si structure in these electrical parameters, and the sample designed in this paper also performs better in electrical parameters than previous studies. These results undoubtedly demonstrate that the combination of High-k material (HfO 2 ) and SiC in the MOS gate oxygen layer is a promising research topic.

First-principles theoretical evaluation of crystalline zirconia and hafnia as gate oxides for Si microelectronics

Microstructure, optical and electrical properties of solution-derived peroxo-zirconium oxide gate dielectrics for CMOS application

Structural and dielectric properties of amorphous ZrO2 and HfO2

Fully solution-induced high performance indium oxide thin film transistors with ZrOx high-k gate dielectrics

First-principles study of oxygen vacancy defects in orthorhombic Hf$_{0.5}$Zr$_{0.5}$O$_2$/SiO$_2$/Si gate stack

First-principles study of oxygen vacancy defects in orthorhombic Hf0.5Zr0.5O2/SiO2/Si gate stack

Tuning the high-κ oxide (HfO2, ZrO2)/4H-SiC interface properties with a SiO2 interlayer for power device applications

An Investigation into the $HfO_2/Si$ Interface: Materials Science Challenges and their Effects on MOSFET Device Performance

Research Progress of High Dielectric Constant Zirconia-Based Materials for Gate Dielectric Application

First-Principles-Based Quantum Transport Simulations of High- Performance and Low-Power MOSFETs Based on Monolayer Ga2O3

Crystalline Zirconia Oxide on Silicon As Alternative Gate Dielectrics

A Nitrided Interfacial Oxide for Interface State Improvement in Hafnium Zirconium Oxide-Based Ferroelectric Transistor Technology

Electronic properties of ZrO<sub>2</sub> films fabricated via atomic layer deposition on 4H-SiC and Si substrates

Electrical Properties of Crystalline YSZ Films on Silicon As Alternative Gate Dielectrics

Production of a hafnium silicate dielectric layer for use as a gate oxide by solid-state reaction

Energetics of intrinsic point defects in ZrSiO$_4$

Structural and Insulating Behaviour of High-Permittivity Binary Oxide Thin Films for Silicon Carbide and Gallium Nitride Electronic Devices

Structural and electrical characterization of Al2O3/HfO2/Al2O3 on strained SiGe

Phase stability of hafnium oxide and zirconium oxide on silicon substrate

Electrical Characterization of HfO2/4H-SiC and HfO2/Si MOS Structures

Band alignments and defect levels in Si–HfO2 gate stacks: Oxygen vacancy and Fermi-level pinning