Abstract:The petrochemical secondary effluent (PSE) is typical refractory wastewater derived from the petrochemical industries, which requires advanced treatment due to the strict environmental protection policies. Catalytic ozonation is one of the most widely used advanced oxidation technologies in wastewater treatment because of its high mineralization rate, in which the alumina-based catalyst usually plays an important role. Extrusion-spheronization is a promising technique for the preparation of alumina spheres because the synthesized alumina particles have high sphericity, high specific surface aera and narrow particle size distribution. In this paper, two kinds of alumina-based catalysts (catalyst A: manganese nitrate added after alumina granulation and catalyst B: manganese nitrate added into alumina powder before granulation) were prepared by the extrusion-spheronization method and used for PSE treatment by catalytic ozonation. The prepared alumina samples were characterized by Brunauer–Emmett–Teller (BET) method, X-ray photoelectron spectroscopy (XPS), X-ray diffraction (XRD) and scanning electron microscopy (SEM), while the wastewater samples were analyzed for Total organic carbon (TOC), UV 254 and fluorescence spectroscopy. Results showed that manganese was uniformly distributed in both catalysts, and the specific surface area of two catalysts was 318.36 m 2 /g and 354.95 m 2 /g, respectively. Catalytic ozonation experiments were repeated nine times with each catalyst under the same conditions. The TOC removal rates for catalysts A and B in the first run were 48.88% and 49.06%, respectively, then it dropped to 28.05% for catalyst A but remained 47.81% for catalyst B after using for nine times. This implied that the long-term performance of catalyst B would be more stable than catalyst A. Similar result were found in three-dimensional fluorescence analysis. UV 254 results indicated that the removal efficiency of aromatic and unsaturated substances by catalyst B was higher than catalyst A. A possible explanation is that the active component manganese oxide formed a catalyst skeleton in catalyst B, which makes it hard to dissolve.

Mn (Cex)/γ-Al2O3 Catalysts with Notably Improved Performances for Catalytic Ozonation of Pollutants in Petroleum Refinery Wastewater

Refractory organic compounds in coal chemical wastewater treatment by catalytic ozonation using Mn-Cu-Ce/Al2O3

Enhanced Activity And Stability Of Copper Oxide/Gamma-Alumina Catalyst In Catalytic Wet-Air Oxidation: Critical Roles Of Cerium Incorporation

Enhanced Ozonation of Polystyrene Nanoplastics in Water with CeOx@MnOx Catalyst.

Highly stable and efficient calcined γ-Al2O3 catalysts loaded with MnOx-CeOx for the ozonation of oxytetracycline

Promoting Metal Oxides–zeolite Electron Interaction on MnCeOx/HY Catalyst for Boosting Nitrogen Oxides Reduction

Heterogeneous Catalytic Ozonation of Refinery Wastewater over Alumina-Supported Mn and Cu Oxides Catalyst

Γ-Al2o3 Doped with Cerium to Enhance Electron Transfer in Catalytic Ozonation of Phenol

Synergistic mechanism of supported Mn–Ce oxide in catalytic ozonation of nitrofurazone wastewater

Manganese-Based Catalysts for the Catalytic Remediation of Phenolic Acids by Ozone

Effect of impregnation strategy on structural characteristics of Ce–Mn/Al2O3 and its catalytic ozonation of benzoic acid

Ce-doped LaMnO3-δ Perovskite As an Efficient Ozonation Catalyst for the Degradation of High-Concentration Phenol Wastewater

Preparation of mesoporous Ce-Ti oxide millispheres for efficient catalytic ozonation: Performance and mechanism

Enhanced catalytic performance for toluene combustion via Ce-doped α-MnO2: efficient balance between toluene adsorption and activation oxidation

Vacuum-treated MnxCe1-xO2 nanorods for catalytic ozonation of 1,2-dichloroethane

Enhanced Activity and Water Tolerance Promoted by Ce on MnO/ZSM-5 for Ozone Decomposition.

Promoting Effect and Role of Alkaline Earth Metal Added to ZrO2-TiO2-supported CeO2 for Dichloromethane Oxidation

Ce-doped LaMnO 3- δ perovskite as an efficient ozonation catalyst for the degradation of high-concentration phenol wastewater

Efficient activation of peroxymonosulfate by Co-doped mesoporous CeO2 nanorods as a heterogeneous catalyst for phenol oxidation

Facile synthesis of Mn, Ce co-doped g-C3N4 composite for peroxymonosulfate activation towards organic contaminant degradation

Effect of extrusion-spheronization granulation and manganese loading on catalytic ozonation of petrochemical wastewater