Engineering Clostridium cellulovorans for highly selective n ‐butanol production from cellulose in consolidated bioprocessing

Teng Bao,Wenjie Hou,Xuefeng Wu,Li Lu,Xian Zhang,Shang‐Tian Yang

DOI: https://doi.org/10.1002/bit.27789

IF: 3.8

2021-04-23

Biotechnology and Bioengineering

Abstract:<p>Cellulosic <i>n</i>‐butanol from renewable lignocellulosic biomass has gained increased interest. Previously, we have engineered <i>Clostridium cellulovorans</i>, a cellulolytic acidogen, to overexpress the bifunctional butyraldehyde/butanol dehydrogenase gene <i>adh</i>E2 from <i>Clostridium acetobutylicum</i> for <i>n</i>‐butanol production from crystalline cellulose. However, butanol production by this engineered strain had a relatively low yield of ~0.22 g/g cellulose due to the co‐production of ethanol and acids. We hypothesized that strengthening the carbon flux through the central butyryl‐CoA biosynthesis pathway and increasing intracellular NADH availability in <i>C</i>. <i>cellulovorans adh</i>E2 would enhance <i>n</i>‐butanol production. In this study, thiolase (<i>thl</i>A^CA) from <i>Clostridium acetobutylicum</i> and 3‐hydroxybutyryl‐CoA dehydrogenase (<i>hbd</i>^CT) from <i>Clostridium tyrobutyricum</i> were overexpressed in <i>C</i>. <i>cellulovorans adh</i>E2 to increase the flux from acetyl‐CoA to butyryl‐CoA. In addition, ferredoxin‐NAD(P)⁺ oxidoreductase (<i>fnr</i>), which can regenerate the intracellular NAD(P)H and thus increase butanol biosynthesis, was also overexpressed. Metabolic flux analyses showed that mutants overexpressing these genes had a significantly increased carbon flux toward butyryl‐CoA, which resulted in increased production of butyrate and butanol. The addition of methyl viologen as an electron carrier in batch fermentation further directed more carbon flux towards <i>n</i>‐butanol biosynthesis due to increased reducing equivalent or NADH. The engineered strain <i>C</i>. <i>cellulovorans adh</i>E2‐<i>fnr</i>^CA‐<i>thl</i>A^CA‐<i>hbd</i>^CT produced <i>n</i>‐butanol from cellulose at a 50% higher yield (0.34 g/g), the highest ever obtained in batch fermentation by any known bacterial strain. The engineered <i>C</i>. <i>cellulovorans</i> is thus a promising host for <i>n</i>‐butanol production from cellulosic biomass in consolidated bioprocessing.</p><p>This article is protected by copyright. All rights reserved.</p>

biotechnology & applied microbiology

What problem does this paper attempt to address?

The main problem that this paper attempts to solve is to improve the efficiency of n - butanol production from cellulose biomass in the consolidated bioprocessing. Specifically, the researchers have modified Clostridium cellulovorans through metabolic engineering means to enhance its ability to produce n - butanol from cellulose. The following are the key issues mentioned in the paper:

1. **Increasing n - butanol production**: In previous studies, although C. cellulovorans was able to produce n - butanol from crystalline cellulose by over - expressing the bifunctional butyraldehyde/butanol dehydrogenase gene adhE2 from C. acetobutylicum, its production was relatively low, approximately 0.22 g/g cellulose. This was mainly due to the simultaneous production of ethanol and other acid by - products. Therefore, the researchers hope to increase the production of n - butanol through further metabolic engineering.

2. **Increasing carbon flux and NADH availability**: The researchers hypothesized that by strengthening the carbon flux in the central butyryl - CoA biosynthesis pathway and increasing the intracellular NADH availability, the production of n - butanol could be increased. To this end, they over - expressed the thiolase gene thlA from C. acetobutylicum, the 3 - hydroxybutyryl - CoA dehydrogenase gene hbd from C. tyrobutyricum, and the ferredoxin - NAD(P)+ reductase gene fnr from C. acetobutylicum.

3. **Optimizing fermentation conditions**: To further increase the production of n - butanol, the researchers also added methyl violet as an electron carrier during the fermentation process to increase the intracellular NADH pool, thereby promoting the biosynthesis of n - butanol.

Through these strategies, the researchers successfully increased the production of n - butanol to 0.34 g/g cellulose, which is the highest production obtained from cellulose biomass by any known bacterial strain in batch fermentation so far. This makes the engineered C. cellulovorans a promising host for the production of n - butanol from cellulose biomass.