Abstract:In this paper, the influences of Al substitution and BaCu(B2O5) (BCB2) additives on the sintering temperature, microstructures, phase structures and microwave properties were investigated in detail. The results indicated that all Al added Ca(0.35)Li(0.25)Nd(0.35)Ti(1-x)AlxO(3) (CLNTA(x)) samples were crystallized as orthorhombic perovskite structure in Pnma space group. A proper amount (x <= 0.03) of Al substitution for Ti was beneficial to improve the quality factors mainly due to the increase of packing fraction. But the permittivity (er) and temperature coefficient of the resonant frequency (T-f) deteriorated because of the decrease of B-site bond valence. The perovskite structured phase and BCB2 phase were observed in Ca0.35Li0.25Nd0.35Ti0.97Al0.03O3 (CLNTA3) ceramics, when a small amount of BCB2 was added (y <= 5 wt%). The sintering temperature was effectively lowered under 950 degrees C, and T-f was modified from 74.8 ppm/degrees C to 41.2 ppm/degrees C with the assistance of BCB2 phase and liquid phase. But excessive BCB2 contents (y > 5 wt %) resulted in the BaNd2Ti5O14 and unknown phase, leading to inferior dielectric properties. Therefore, 5 wt% BCB2-added CLNTA3 ceramics sintered at 950 degrees C for 2 h exhibited excellent comprehensive microwave dielectric properties: e(r) = 109.5, Q x f = 2979 GHz and t(f) = 41.2 ppm/degrees C. (C) 2016 Elsevier B.V. All rights reserved.

Ultralow-Permittivity and Temperature-Stable Ba 1- x Ca x Mg 2 Al 6 Si 9 O 30 Dielectric Ceramics for C-Band Patch Antenna Applications

Crystal Structure, Infrared Reflectivity Spectra and Microwave Dielectric Properties of CaAl2O4 Ceramics with Low Permittivity

Low-temperature Co-Fired Ceramics with High Thermal Expansion and Reliability for Millimeter-Wave Antennas

Design and Fabrication of a C-Band Patch Antenna with Low Loss BaM 4 Si 5 O 17 Microwave Dielectric Ceramics

Crystal Structure, Vibrational Spectroscopy, and Microwave Dielectric Properties of CaAl4O7 Ceramics with Low Permittivity

Crystal Structure and Temperature Dependence of Permittivity in Barium Aluminate Based Solid Solutions

Microwave Dielectric Properties of Na+-substituted CaMg0.9Li0.2Si2O6 Ceramics

Low-temperature Firing and Microwave Dielectric Properties of (1−X)ca5mg4(vo4)6-Xba3(vo4)2 Temperature Stable Ceramics

Synthesis of CaAl2xB2O4+3x: Novel Microwave Dielectric Ceramics with Low Permittivity and Low Loss

Low-temperature sintering and microwave dielectric properties of CaMg1−xLi2xSi2O6 (x = 0−0.3) ceramics

Ba4LiNb3-xSbxO12: Phase evolution, microstructure and optimized microwave dielectric properties

Ultra low loss (Mg 1 − x Ca x ) 2 SiO 4 dielectric ceramics (x = 0 to 0.15) for millimeter wave applications

Enhanced Dielectric and Ferroelectric Characteristics in Ca-Modified Batio3 Ceramics

Low-temperature sintering and microwave dielectric properties of CaMg 1− x Li 2 x Si 2 O 6 ( x = 0−0.3) ceramics

Ultra-low temperature sintered (1–x)BaV2O6-xLiF ceramics for ULTCC and 5 G millimeter-wave antenna applications

Low Temperature Sintering of High Permittivity Ca-Li-Nd-Ti Microwave Dielectric Ceramics with BaCu(B2O5) Additives

Crystal Structures and Microwave Dielectric Properties of Novel Low Permittivity Ba1-xSrxZnSi3O8 Ceramics

Ultra Low Loss (mg1 − Xcax)2sio4dielectric Ceramics (x = 0 to 0.15) for Millimeter Wave Applications

Structure Evolution and Microwave Dielectric Characteristics of Ca[(Alxga0.5-Xnb0.5)(0.5)Ti-0.5]O-3 Ceramics

Microwave Dielectric Properties of Mg1.8R0.2Al4Si5O18 (R = Mg, Ca, Sr, Ba, Mn, Co, Ni, Cu, Zn) Cordierite Ceramics and Their Application for 5G Microstrip Patch Antenna

Low temperature firing and microwave dielectric properties of BaCaV2O7 ceramics