Abstract:The automotive industry has begun to shift to new energy electric vehicles due to the challenges of oil and environmental resources. However, heating in low-temperature environments results in poor endurance of electric vehicles in winter, which has always hindered the development of electric vehicles. The main reason is that the commonly used heating method, Positive Temperature Coefficient Heating (PTC), has a lower efficiency, while traditional heat pumps lack heat absorption and heat exchanger frosting, resulting in heat pumps not being able to be used well in low-temperature environments. This article proposes a transcritical CO2 self-enhanced enthalpy heat pump system suitable for low-temperature environmental applications to address this issue. The system can be divided into self-enhanced enthalpy heat pump (SEHP) mode, self-enhanced enthalpy waste heat hybrid heat pump (SEWHHP) mode, and waste heat recovery heat pump (WHHP) mode based on no waste heat, low waste heat to high waste heat. A mathematical analysis was conducted on the operating characteristics of CO2 in three modes using the AMESIM platform. The heat from the condenser in the system can be distributed by the cooling water circuit to the cabin and evaporator for heat absorption, and the waste heat from the battery motor can also be well utilized by the evaporator. This article focuses on analyzing the efficiency of three modes under different ambient temperatures, target temperatures, and residual heat. When the ambient temperature is - 20degree celsius, the mode switches from the SEHP to the SEWHHP mode and then to the WHHP mode, with the efficiency increasing from 0.89 to 1.31 and 1.77, respectively. COP increases with increasing ambient temperature in all modes, with the WHHP mode increasing from 1.46 to 1.67 when the ambient temperature increases from 50 degrees C to 20 degrees C. The efficiency is much greater than that of PTC, and this study provides new ideas for the thermal management of electric vehicles in low-temperature environments.

Experimental study and exergy analysis of electric vehicle single-stage compression secondary throttling CO 2 air-source heat pump system in cold climate

Performance Investigation on an Air Source Heat Pump System with Latent Heat Thermal Energy Storage

Simulation Study on Performance of an Air Source Heat Pump System Combined with Phase Change Thermal Storage Using Alternative Refrigerants

Performance Optimization and Economic Evaluation of CO2 Heat Pump Heating System Coupled with Thermal Energy Storage

Experimental Performance Analysis and Evaluation of a Novel Frost-Free Air Source Heat Pump System

Study on Efficient Heating Method by Solar Coupled Air Source Heat Pump System with Phase Change Heat Storage in Severe Cold Region

Heating Control Strategy of CO2 Heat Pump Air Conditioning System of Electric Vehicle Based on Waste Heat Recovery Technology

Experimental investigation on thermal characteristics of transcritical CO2 heat pump unit combined with thermal energy storage for residential heating

Heating Performance Evaluation of a CO2 Heat Pump System for an Electrical Vehicle at Cold Ambient Temperatures

Self-enhanced Enthalpy Heat Pump System Based on the Performance of CO2 Whole-Vehicle Thermal Management below −20 °C

Experimental Investigations on the Performance of a Single-Stage Compound Air-Source Heat Pump Using CO2/R600a in Cold Regions

Experimental Investigation and Theoretical Analysis of Heat Pump Systems with Two Different Injection Portholes Compressors for Electric Vehicles

Heating Performance Characteristics of CO2 Heat Pump System for Electrical Vehicle in a Cold Climate

Performance Comparison of Air-source Heat Pumps Using Economizer Vapor Injection and Internal Heat Exchanger in Cold Regions

Performance Analysis and Operation Optimization of Air-to-water CO2 Heat Pump with Phase Change Thermal Storage

Experimental investigation on the heating performance of a CO2 heat pump system with intermediate cooling for electric vehicles

Experimental Study on Heating Performance of a CO2 Heat Pump System for an Electric Bus

Self-enhanced enthalpy heat pump system based on the performance of CO 2 whole-vehicle thermal management below −20 °C

Experimental Investigation on Heating Performance of Heat Pump for Electric Vehicles at −20 °C Ambient Temperature

Experimental Investigation on Heating Performance of Heat Pump for Electric Vehicles in Low Ambient Temperature.

Operation strategy and performance investigation of a high-efficiency multifunctional two-stage vapor compression heat pump air conditioning system for electric vehicles in severe cold regions