Abstract:The automotive industry has begun to shift to new energy electric vehicles due to the challenges of oil and environmental resources. However, heating in low-temperature environments results in poor endurance of electric vehicles in winter, which has always hindered the development of electric vehicles. The main reason is that the commonly used heating method, Positive Temperature Coefficient Heating (PTC), has a lower efficiency, while traditional heat pumps lack heat absorption and heat exchanger frosting, resulting in heat pumps not being able to be used well in low-temperature environments. This article proposes a transcritical CO2 self-enhanced enthalpy heat pump system suitable for low-temperature environmental applications to address this issue. The system can be divided into self-enhanced enthalpy heat pump (SEHP) mode, self-enhanced enthalpy waste heat hybrid heat pump (SEWHHP) mode, and waste heat recovery heat pump (WHHP) mode based on no waste heat, low waste heat to high waste heat. A mathematical analysis was conducted on the operating characteristics of CO2 in three modes using the AMESIM platform. The heat from the condenser in the system can be distributed by the cooling water circuit to the cabin and evaporator for heat absorption, and the waste heat from the battery motor can also be well utilized by the evaporator. This article focuses on analyzing the efficiency of three modes under different ambient temperatures, target temperatures, and residual heat. When the ambient temperature is - 20degree celsius, the mode switches from the SEHP to the SEWHHP mode and then to the WHHP mode, with the efficiency increasing from 0.89 to 1.31 and 1.77, respectively. COP increases with increasing ambient temperature in all modes, with the WHHP mode increasing from 1.46 to 1.67 when the ambient temperature increases from 50 degrees C to 20 degrees C. The efficiency is much greater than that of PTC, and this study provides new ideas for the thermal management of electric vehicles in low-temperature environments.

Operation strategy and performance investigation of a high-efficiency multifunctional two-stage vapor compression heat pump air conditioning system for electric vehicles in severe cold regions

Performance Analysis of a Novel Hybrid Vapor Injection Cycle with Subcooler and Flash Tank for Air-Source Heat Pumps

Performance Analysis and Operation Strategy of a Dual-Evaporation Temperature Heat Pump System for Electric Vehicles in Winter

Heating Performance Characteristics of an Electric Vehicle Heat Pump Air Conditioning System Based on Exergy Analysis

Simulation Study on Performance of an Air Source Heat Pump System Combined with Phase Change Thermal Storage Using Alternative Refrigerants

Global Selection Appraisal Study for Heat Pump System of Electric Vehicle Based on Energetic, Economic, and Environmental Analysis

Experimental and Theoretical Assessments on the Systematic Performance of a Single-Stage Air-Source Heat Pump Using Ternary Mixture in Cold Regions

Investigation on the performance and characteristics of a heat pump system for electric vehicles under extreme temperature conditions

Performance Analysis of an R290 Vapor-Injection Heat Pump System for Electric Vehicles in Cold Regions

Heating performance of heat pump air conditioning system for battery electric vehicle with different refrigerants

Experimental Investigations on the Performance of a Single-Stage Compound Air-Source Heat Pump Using CO2/R600a in Cold Regions

Performance Study of Phase Change Charging/discharging Processes of Condensing Heat Storage in Cold Regions Based on a Mathematical Model

Performance Investigation on an Air Source Heat Pump System with Latent Heat Thermal Energy Storage

Heating Control Strategy of CO2 Heat Pump Air Conditioning System of Electric Vehicle Based on Waste Heat Recovery Technology

Study on Efficient Heating Method by Solar Coupled Air Source Heat Pump System with Phase Change Heat Storage in Severe Cold Region

Self-enhanced Enthalpy Heat Pump System Based on the Performance of CO2 Whole-Vehicle Thermal Management below −20 °C

Performance Investigation on a Novel Air-Source Heat Pump Using CO2/HC for Recirculated Water Heater in Cold Regions

Self-enhanced enthalpy heat pump system based on the performance of CO 2 whole-vehicle thermal management below −20 °C

A Study on Electric Vehicle Heat Pump Systems in Cold Climates

Heating Performance Evaluation of a CO2 Heat Pump System for an Electrical Vehicle at Cold Ambient Temperatures

Enhance the Heating Performance of an Electric Vehicle AC/HP System under Low Temperature