Abstract:In this work, experiment was conducted to examine the thermo-physical properties of an alternative refrigerant to HCFC-22 in the presence of polyol ester (POE). The new alternative refrigerant is a mixture of HFC-32/125/161, whose physical properties are similar to HCFC-22 but has a lower global warming potential (GWP) than that of R407C. POE is used as the tested lubricating oil in the experiment. The saturated vapor pressure data and vapor–liquid equilibrium data of nine different mass fractions of the new refrigerant and polyol ester (POE) in the temperature range of 253–323K were measured by single-phase cycle method. The experiment results showed that there was no stratification, no sediment generation in the liquid phase of the mixture, and the color of liquid phase of the mixture had no change in the equilibrium cell before and after the experiment with the POE concentration greater than 20% and the temperature higher than 258K; with POE concentration lower than 20% and temperature lower than 258K, stratification began to appear. Meanwhile, when POE and the refrigerant were miscible, the saturated pressure data of the mixture (HFC-32/125/161+POE) revealed that POE had a very small impact on saturated vapor pressure of the mixture (almost negligible) when POE was less than 10% of the mixture; POE has an obvious effect on the saturated vapor pressure of the mixture when there is more than 10% POE in the mixture, especially when the temperature is higher than 283.15K. Experimental data were correlated by Flory–Huggins model, Heil model, NRTL model and Wilson model. The results showed that to the average and maximum pressure deviation, the results were better with considering the effects of temperature on the energy parameters. Among the above models, the NRTL activity coefficient model was the best, the Heil and Wilson models followed and the Flory–Huggins model had the largest deviation from the experimental data.

Experimental Investigation on the Surface Tension of R1234ze(E)/POE Lubricant Mixtures from 278 K to 338 K

Experimental Data and Description of the Phase Equilibrium in the Binary System of Ethyl Fluoride and Polyol Ester Oil (planetelf ACD 32)

Solubility And Miscibility For The Mixture Of (Ethyl Fluoride Plus Polyol Ester Oil)

Isothermal Vapor–Liquid Equilibria of the Absorption Working Pairs (r1234yf + NMP, R1234yf + DMETrEG) at Temperatures from 293.15 K to 353.15 K

Measurements of the Isobaric Heat Capacity of Pressurized Liquid Trans-1,3,3,3-tetrafluoropropene [r1234ze(e)] by Scanning Calorimetry

Experimental Investigation of Vapor–Liquid Equilibrium for 2,3,3,3-Tetrafluoropropene (Hfo-1234Yf) + Trans-1,3,3,3-tetrafluoropropene (Hfo-1234Ze(e)) at Temperatures from 284 to 334 K

Vapor–Liquid Equilibrium for the Binary Systems 1,1,2,3,3,3-Hexafluoro-1-propene (R1216) + 2,3,3,3-Tetrafluoroprop-1-ene (r1234yf) and 1,1,2,3,3,3-Hexafluoro-1-propene (R1216) + Trans-1,3,3,3-tetrafluoropropene (R1234ze(e))

Effect of viscosity grade (POE) on the smooth-tube pool boiling performance with R-1234ze(E) refrigerant

Solubility and Miscibility for the Mixture of (ethyl Fluoride + Alkylbenzene Oil)

Nucleate boiling heat transfer of R-134a and R-134a/POE lubricant mixtures on smooth tube

Mutual Diffusivities of Difluoromethane and 2,3,3,3-Tetrafluoropropylene Dissolved in Polyalkylene Glycol Lubricant

Experimental Speed of Sound in Two Emerging Mixture Working Fluids of [r1234ze(z) + R1233zd(E)] and [r1234ze(z) + Isobutane]

Experimental studies on a mixture of HFC-32/125/161 as an alternative refrigerant to HCFC-22 in the presence of polyol ester

Experimental Investigation on the Inhibition of Flame Retardants on the Flammability of R1234ze(E)

Vapor-liquid Equilibrium Measurements for the Binary Mixtures of 1,1-Difluoroethane (r152a) with Trans-1,3,3,3-tetrafluoropropene (r1234ze(e)) and 3,3,3-Trifluoropropene (R1243zf)

Vapor-liquid Equilibrium Measurements and Models for the Ternary Mixtures of R1234yf + R32 + R125 and R1234yf + R32 + CO2

The investigation of evaporation behavior of lubricating oil droplet at high ambient temperature

Experimental Investigation of Lubrication Properties at High Contact Pressure

Vapor-liquid Equilibrium Measurements for the Binary Mixtures of Pentafluoroethane (R125) with 2,3,3,3-Tetrafluoroprop-1-ene (r1234yf) and 3,3,3-Trifluoropropene (R1243zf)

Effect of oil concentration, viscosity, and surface tension on tube temperature and heat transfer coefficients of R1234ze(E)/oil spray evaporation on an enhanced tube bundle

Surface tension calculation of liquid mixtures by PR EOS