Abstract:Increasing the power density of polymer electrolyte membrane fuel cells (PEMFCs) is vital for their commercial application but requires detailed knowledge of the charge, oxygen, and water transport mechanisms. In this study, an improved multi-phase non-isothermal PEMFC model coupled with a detailed catalyst-layer (CL) agglomerate model is developed to investigate the performance characteristics under different operating conditions and hydrophobic porous electrode designs. During the parametric analysis, the oxygen and charge transport behaviors on cell performance are analyzed, the contributions of bulk and local oxygen transport to the entire oxygen transport process are revealed, and the corresponding water retention, drainage, and transport are evaluated to clarify the internal mechanisms of oxygen transport and membrane hydration. It is found that an increase in temperature can accelerate the membrane water back diffusion and hence improve the sluggish charge transport. Increasing the relative humidity (RH) enhances the cell performance. The local oxygen and charge transport resistances decrease with an increase in the RH owing to the higher membrane hydration. The presence of microporous layer (MPL) improves the liquid-water retention capacity, deteriorating the bulk oxygen transport due to liquid-water blockage but leading to more rapid local oxygen transport and charge conduction. The optimum performance improvement obtained using an MPL occurs in the moderate cathode humidification scheme (50%). A low-hydrophobicity CL tends to induce a large bulk oxygen transport resistance due to severe water flooding. An optimum hydrophobic electrode design is recommended to realize a tradeoff of oxygen and charge transport, which consist of a super-hydrophobicity gas diffusion layer (contact angle 120 degrees), low-hydrophobicity MPL (contact angle 105 degrees), and middle-hydrophobicity CL (contact angle 95 degrees). (C) 2022 Elsevier B.V. All rights reserved.

Numerical studies on porous water transport plates applied in PEMFCs under pure oxygen condition

In-Depth Understanding of Oxygen Transfer in the Catalyst Layer of High-Temperature Proton Exchange Membrane Fuel Cells

Numerical Modeling and Performance Prediction of Water Transport for PEM Fuel Cell

Numerical studies of liquid water behaviors in PEM fuel cell cathode considering transport across different porous layers

Numerical Modeling of Liquid Water Transport Inside and Across Membrane in PEM Fuel Cells

Numerical Studies of Interfacial Phenomena in Liquid Water Transport in Polymer Electrolyte Membrane Fuel Cells Using the Lattice Boltzmann Method

Pore-scale simulation of oxygen transport in a proton exchange membrane electrolysis cell: Effect of the hydrophilia of porous transport layer and catalytic layer

Water saturation distribution in a PEMFC at the cathode side using OpenFOAM

Study on water and oxygen transfer characteristics of HT-PEM fuel cells

Mass Transfer Through the Interface Between Catalyst Layer and Separator in PEMFCs under Flooding/drying Conditions

Numerical Study on Oxygen Transport Pattern in Porous Transport Layer of Proton Exchange Membrane Electrolysis Cells

Modeling of the Effect of Ionomer Volume Fraction on Water Management for Proton Exchange Membrane Fuel Cell

Experimental and Numerical Analysis of A Three-Dimensional Flow Field for Pemfcs

Modeling Analysis of Polymer Electrolyte Membrane Fuel Cell with Regard to Oxygen and Charge Transport under Operating Conditions and Hydrophobic Porous Electrode Designs

Recent advances in heat and water management of forced-convection open-cathode proton exchange membrane fuel cells

Control-oriented Modeling and Exploration of Hygrothermal Characteristics of Air-Cooled Proton Exchange Membrane Fuel Cell

Improvement of Thermal and Water Management of Air-Cooled Polymer Electrolyte Membrane Fuel Cells by Adding Porous Media into the Cathode Gas Channel

NUMERICAL INVESTIGATION OF THE COUPLED WATER AND THERMAL MANAGEMENT IN PEM FUEL CELL

Numerical Investigation of Cathode Water Management in Direct Methanol Fuel Cell with Micro-porous Layer

Two-dimensional Pore-Scale Investigation of Liquid Water Evolution in the Cathode of Proton Exchange Membrane Fuel Cells

Numerical Study of Water Transport and Operating Strategy for Fuel Cells with Segmented Water Management Flow Fields