Abstract:This study proposed and examined a new process flowsheet for treating neutral mine drainage (NMD) from an open-pit gold mine. The process consisted of three sequential stages: (1) in situ hydrotalcite (HT) precipitation; (2) low-cost carbon substrate driven microbial sulfate reduction; and (3) ferrosol reactive barrier for removing biogenic dissolved hydrogen sulfide (H 2 S). For concept validation, laboratory-scale columns were established and operated for a 140-days period with key process performance parameters regularly measured. At the end, solids recovered from various depths of the ferrosol column were analysed for elemental composition and mineral phases. Prokaryotic microbial communities in various process locations were characterised using 16S rRNA gene sequencing. Results showed that the Stage 1 HT-treatment substantially removed a range of elements (As, B, Ba, Ca, F, Zn, Si, and U) in the NMD, but not nitrate or sulfate. The Stage 2 sulfate reducing bioreactor (SRB) packed with 70 % (v/v) Eucalyptus woodchip, 1 % (w/v) ground (<1 mm) dried Typha biomass, and 10 % (w/v) NMD-pond sediment facilitated complete nitrate removal and stable sulfate removal of ca. 50 % (50 g-SO 4 m −3 d −1 ), with an average H 2 S generation rate of 10 g-H 2 S m −3 d −1 . The H 2 S-removal performance of the Stage 3 ferrosol column was compared with a synthetic amorphous Fe-oxyhydroxide-amended sand control column. Although both columns facilitated excellent (95–100 %) H 2 S removal, the control column only enabled a further ca. 10 % sulfate reduction, giving an overall sulfate removal of 56 %. In contrast, the ferrosol enabled an extra 99.9 % sulfate reduction in the SRB effluent, leading to a near complete sulfate removal. Overall, the process successfully eliminated a range of metal/metalloid contaminants, nitrate, sulfate (2500 mg-SO 4 L −1 in the NMD to <10 mg-SO 4 L −1 in the final effluent) and H 2 S (>95 % removal). Further optimisation is required to minimise release of ferrous iron from the ferrosol barrier into the final effluent.

Simultaneous Aeration and Neutralization of Mine Water: An Apparently Forgotten Discovery

Effectiveness of amendments on re-acidification and heavy metal immobilization in an extremely acidic mine soil

Review of Passive Systems for Acid Mine Drainage Treatment

Natural pretreatment and passive remediation of highly polluted acid mine drainage

The economic pre-treatment of coal mine drainage water with caustic and ozone

A review of passive acid mine drainage treatment by PRB and LPB: From design, testing, to construction

Assessing the long-term evolution of mine water quality in abandoned underground mine workings using first-flush based models

Evaluation of Dispersed Alkaline Substrate and Diffusive Exchange System Technologies for the Passive Treatment of Copper Mining Acid Drainage

Passive Removal of Mn from Mine Water Using Oxic Aggregate Beds: Results of Two Pilot Systems

Sequential hydrotalcite precipitation, microbial sulfate reduction and in situ hydrogen sulfide removal for neutral mine drainage treatment

Mechanisms of water-rock interaction and implications for remediating flooded mine workings elucidated from environmental tracers, stable isotopes, and rare earth elements

Effective co-treatment of synthetic acid mine drainage and domestic sewage using multi-unit passive treatment system supplemented with silage fermentation broth as carbon source

An Optimized Combination of Mine Water Control, Treatment, Utilization, and Reinjection for Environmentally Sustainable Mining: A Case Study

Sulphidogenic Bioprocesses for Acid Mine Water Treatment and Selective Recovery of Arsenic and Metals

The Potential Use of Exhausted Open Pit Mine Voids as Sinks for Atmospheric CO2: Insights from Natural Reedbeds and Mine Water Treatment Wetlands

The Use of Mining Waste Materials for the Treatment of Acid and Alkaline Mine Wastewater

Biological Remediation of Acid Mine Drainage: Review of Past Trends and Current Outlook.

Co-treatment of abandoned mine drainage and Marcellus Shale flowback water for use in hydraulic fracturing

Laboratory simulation of the swampy forest system for the passive treatment of acid mine drainage in coal mine reclamation areas

Acid mine drainage from coal mining in the United States – An overview

Use of a Waste-Derived Linde Type-A Immobilized in Agarose for the Remediation of Water Impacted by Coal Acid Mine Drainage at Pilot Scale