Abstract:In consolidation of AlON, the extensive decomposition of AlON into α-Al2O3 and AlN during sintering is one of the major reasons that significantly retard its densification process. To accelerate densification of AlON, an ultra-low concentration of La2O3 (0.03 wt%) and Y2O3 (0.02-0.04 wt%) was co-doped as sintering additives to inhibit decomposition of AlON during sintering for fast fabrication of highly transparent AlON ceramics. The phase transformation, microstructure evolution and densification process of the samples undoped and doped additive during heating were studied to investigate the densification mechanism. The results reveal that, compared to the samples undoped additive and single-doped with La2O3, the α-Al2O3 content of the samples co-doped with La2O3 and Y2O3 is significantly deduced at ≤1600 °C, which indicates that the decomposition of AlON is effectively inhibited by co-doping La2O3 and Y2O3. The reduction of α-Al2O3 along with the deceleration effect of La3+ on mass transfer, contributes to more small particles being conserved at high temperatures. Base on this, at later stage of sintering, benefiting from the enhanced mobility of grain boundary by Y3+, AlON ceramics with high relative density (99.79 %) and excellent transparency were obtained via pressureless sintering at 1880 °C for 2.5 h by co-doping 0.03 wt% La2O3 and 0.04 wt% Y2O3. The maximum transmittance of the fabricated AlON ceramics is up to 81.6 % at 3600 nm, and a transmittance of 76.0 % was measured at 400 nm. The ultra-low doping amount of La2O3 and Y2O3 and the high relative density should be the main reasons that lead to the outstanding transparency of the obtained AlON. Additionally, the fabricated AlON ceramics also exhibit a high Vickers hardness of 18.89 ± 0.18 GPa.

Fabrication and properties of highly transparent Li0.07Al2.76O3.64N0.36 ceramics by aqueous gelcasting and two-step preparation

A new quaternary Li0.19Al2.72O3.64N0.36 transparent ceramic with high hardness

The hydrolysis process of γ-AlON powder and preparation of highly transparent ceramics with aqueous gel-casting

Preparation and optical properties of highly transparent MgAl1.9Ga0.1O4 ceramics via aqueous gel-casting method

Preparation of transparent MgAlON ceramics with tunable compositions

Transmittance enhancement of La0.4Gd1.6Zr2O7 transparent ceramic by aqueous AM gel-casting with pretreated powder

Fabrication of highly transparent AlON ceramics by inhibiting decomposition of AlON

Influence of Al2O3/SiO2 ratio in multicomponent LNAS glasses and glass-ceramics on the crystallization behavior, microstructure and mechanical performance

Fabrication of Transparent LaAlO3/t-ZrO2 Nanoceramics Through Controlled Amorphous Crystallization

Rapid fabrication of extremely thin Nano-Al2O3 transparent ceramic wafers through nonaqueous tape casting

Crystallization kinetics, structural and mechanical properties of transparent lithium aluminosilicate glass-ceramics

Fabrication, Mechanical and Optical Performance of AM-gel Casted YAG Transparent Ceramics

High transmittance and grain-orientated alumina ceramics fabricated by adding fine template particles

Preparation and microwave dielectric properties of multilayer Li 1.075 Nb 0.625 Ti 0.45 O 3 co-fired ceramics with aqueous tape casting

Highly transparent MgAl0.5Ga1.5O4 ceramic for overcoming the trade-off between infrared transmittance and mechanical properties

Optimizing AlN hydrolysis process to fabricate coated modified powders for improving the properties of Si 3 N 4 /SiAlON ceramics prepared by Vat Photopolymerization

Fabrication of Yb3+-Doped Yag Transparent Ceramics by Aqueous Gelcasting

Investigation of the structural characteristics, dielectric properties, and infrared reflectivity spectra of AlON transparent ceramics

Transparent AlN ceramics sintered from nanopowders produced by the wet chemical method

Direct tape casting of Al2O3/AlN slurry for AlON transparent ceramic wafers via one-step reaction sintering

Compositional tailoring effect on crystal structure, mechanical and thermal properties of γ-AlON transparent ceramics