Abstract:Eutrophication and the predicted limited future availability of rock phosphate has triggered the increased development of phosphorus (P) recovery technologies, however, for remote regions, recovery solutions are still limited. Here, we report on a novel pilot-scale technology (FILTRAFLOTM-P reactor) to recover phosphate (PO43-) from wastewater effluent through a filtration/adsorption process in a rural setting. This unit employs enhanced gravitational filtration through adsorption media (here, a novel KOH deacetylated crab carapace based chitosan-calcite material (CCM)) with continuous self-backwashing. Trials were designed to assess how the FILTRAFLOTM-P unit would operate under 'real' conditions (both at low and high PO43- levels), and to ascertain the effectiveness of the adsorbent to recover phosphate from final effluent. High removal was achieved at low phosphate concentrations, bringing the residual effluent PO43- level below 1 mg/L (EU limit for sensitive water bodies), while phosphate was efficiently harvested (at more than 50%) at higher PO43- levels. Surface microprecipitation and inner-sphere complexation were postulated as the main PO43- adsorption mechanisms through XRD, XPS and EDX elemental mapping. Further, a quality assessment of the P-enriched CCM (which could be used as a potential soil amendment) was undertaken to consider elemental composition, microbiological assessment and quantification of organic micropollutants. Quality analysis indicated ∼2.5% P2O5 present, trace levels (well below legislative limits) of heavy metals and extremely low levels of organic pollutants (e.g., PCBs, pharmaceuticals). No detectable levels of target bacterial pathogens were observed. Pot trials showed that ryegrass cultivated with the addition of the CCM adsorbent achieved higher plant dry matter and P concentration when compared to unfertilised controls, with a slow-release kinetic pattern. This study showed that CCM used with the FILTRAFLOTM-P pilot reactor has high potential to recover phosphate from effluents and encourage resource recovery via bio-based management of waste.

Integrating the Fe2+/H2O2-strengite method in airlift reactor for phosphorus removal and recovery from organic phosphorus wastewater

Phosphorus removal and recovery from wastewater by highly efficient struvite crystallization in an improved fluidized bed reactor

Simultaneous P Release and Recovery from Fish Farm Sludge Using a Zr-modified Magnetic Adsorbent Treated by Ultrasound

Recovery of Phosphorus from Wastewater and Sludge

Remove and Recover Phosphorus During Anaerobic Digestion of Excess Sludge by Adding Waste Iron Scrap

FePO4.2H2O recovery from acidic phosphate-rich waste streams

Recovery of phosphorus resource from a new bidogical wastewater treatment process with on-site reduction of excess sludge

Carbon source and phosphorus recovery from iron-enhanced primary sludge via anaerobic fermentation and sulfate reduction: Performance and future application

The phosphorus harvest from low-temperature mainstream wastewater through iron phosphate crystallization in a pilot-scale partial nitritation/anammox reactor

Phosphorus recovery and resource utilization from phosphogypsum leachate via membrane-triggered adsorption and struvite crystallization approach

Recovering phosphorus as struvite from the concentrated solution produced by the alternating aerobic/anaerobic biofilm system

Enhanced phosphate pollutant removal from liquid via adsorption flotation strategy: Synergic effect of Fe(III)-fulvic acid carrier and CTAB

A novel calcium peroxide/attapulgite-Fe(II) process for high concentration phosphate removal and recovery: Efficiency and mechanism

Acidogenic Phosphorus Recovery from the Wastewater Sludge of the Membrane Bioreactor Systems with Different Iron-Dosing Modes.

Pilot-scale phosphorus recovery from biogas slurry to produce battery-grade FePO 4 : Chemical enhanced primary treatment coupled adsorption process

Highly stable removal of low concentration phosphorus by mechanically activated FeCO 3 : In situ synergistic mechanisms

Efficient phosphorus recovery from waste activated sludge: Pretreatment with natural deep eutectic solvent and recovery as vivianite

Enhanced recovery of phosphorus from hypophosphite-laden wastewater via field-induced electro-Fenton coupled with anodic oxidation

Enhanced Phosphorus Removal from Wastewater Using RSPRC and a Novel Reactor

Rapid and efficient removal of organophosphorus pollutant and recovery of valuable elements: A boosted strategy for eliminating organophosphorus from wastewater

Pilot-scale phosphate recovery from wastewater to create a fertiliser product: An integrated assessment of adsorbent performance and quality