Abstract:Pneumatic submersible pump is a new type of drainage tool in farmland irrigation. The water supply at the pumping end of the submersible pump is sporadic with frequent no-load operation given the low water levels in most rural canals during summer. The change in water flow and pressure directly causes high turbine speed and thus leads to the runaway speed phenomenon, which seriously affects operational safety. A pneumatic control system based on metering-out control was proposed to prevent high turbine speed and minimize the consumption of the pneumatic submersible pump in irrigation and drainage. First, the pneumatic liquid level control system was designed to automatically adjust the pressure and flow of the submersible pump under no-load and load conditions. Second, the stability of the system was simulated by Advanced Modeling and Simulation Environment for Systems Engineering (AMESim), and the coupling relationship among turbine speed, inlet pressure, and flow rate was discussed with different metering-out flows. Finally, comparative experiments were conducted for verification. Simulation and experimental results show that under the no-load condition, when the inlet pressure reaches 0.2 Mpa, the rotating speed of the pneumatic submersible pump increases with the inlet pressure, and when the inlet pressure reaches 0.4 Mpa, the rotating speed of the pneumatic submersible pump remains approximately unchanged. When the outlet flow increases, the rotating speed of the pneumatic submersible pump also increases gradually; when the outlet flow is equal to the inlet flow, the rotating speed remains stable; when the inlet pressure is higher than 0.4 Mpa and the outflow flow is smaller than 18 m/h, the turbine speed can be less than 12000 r/min, which is lower than the critical runaway speed. Thus, the total power loss is not reduced. The control system solves the problem of runaway speed and realizes automatic speed control of the pneumatic submersible pump under the no-load condition. The proposed method provides wide application prospects and is suitable for discontinuous irrigation and drainage operation of rural canals.

Application of Model Predictive Control for Large-Scale Inverted Siphon in Water Distribution System in the Case of Emergency Operation

Optimal Dispatching of Large-scale Water Supply System

Automatic Control of the Middle Route Project for South-to-North Water Transfer Based on Linear Model Predictive Control Algorithm

Predictive control of slurry pressure balance in shield tunneling using diagonal recurrent neural network and evolved particle swarm optimization

Constrained Model Predictive Control Algorithm for Cascaded Irrigation Canals

PDE‐constrained model predictive control of open‐channel systems

Water level predictive control in multi-cascade pools with large control interval demand based on constraint methods

Real-time model predictive control study of run-of-river hydropower plants with data-driven and physics-based coupled model

Coupling model predictive control and rules-based control for real-time control of urban river systems

Real-time model predictive control of urban drainage system in coastal areas

An Adaptive Predictive Control Algorithm for Comprehensive Dendritic Canal Systems

A Model Predictive Water-Level Difference Control Method for Automatic Control of Irrigation Canals

Design and Experimental Study on the Automatic Speed Control System of a Pneumatic Submersible Pump

Model predictive control and rainfall Uncertainties: Performance and risk analysis for drainage systems

Real-time Regulation of Detention Ponds via Feedback Control: Balancing Flood Mitigation and Water Quality

Economic Model Predictive Control of Water Distribution Systems with Accelerated Optimization Algorithm

Real-time control of combined surface water quantity and quality: polder flushing

Enabling Efficient Model-Free Control of Large-Scale Canals by Exploiting Domain Knowledge

Pump/valves coordinate control of the independent metering system for mobile machinery

Water-level based discrete integrated dynamic control to regulate the flow for sewer-WWTP operation

Adaptive Parameter Estimation-Based Predictive Multi-Model Switching Control of Drainage Systems