Abstract:Biohythane production via two-stage fermentation is a promising direction for sustainable energy recovery from lignocellulosic biomass. However, the utilization of lignocellulosic biomass suffers from specific natural recalcitrance. Hydrothermal liquefaction (HTL) is an emerging technology for the liquefaction of biomass, but there are still several challenges for the coupling of HTL and two-stage fermentation. One particular challenge is the limited efficiency of fermentation reactors at a high solid content of the treated feedstock. Another is the conversion of potential inhibitors during fermentation. Here, we report a novel strategy for the continuous production of biohythane from cornstalk through the integration of HTL and two-stage fermentation. Cornstalk was converted to solid and liquid via HTL, and the resulting liquid could be subsequently fed into the two-stage fermentation systems. The systems consisted of two typical high-rate reactors: an upflow anaerobic sludge blanket (UASB) and a packed bed reactor (PBR). The liquid could be efficiently converted into biohythane via the UASB and PBR with a high density of microbes at a high organic loading rate.Biohydrogen production decreased from 2.34 L/L/day in UASB (1.01 L/L/day in PBR) to 0 L/L/day as the organic loading rate (OLR) of the HTL liquid products increased to 16 g/L/day. The methane production rate achieved a value of 2.53 (UASB) and 2.54 L/L/day (PBR), respectively. The energy and carbon recovery of the integrated HTL and biohythane fermentation system reached up to 79.0 and 67.7%, respectively. The fermentation inhibitors, i.e., 5-hydroxymethyl furfural (41.4-41.9% of the initial quantity detected) and furfural (74.7-85.0% of the initial quantity detected), were degraded during hydrogen fermentation. Compared with single-stage fermentation, the methane process during two-stage fermentation had a more efficient methane production rate, acetogenesis, and COD removal. The microbial distribution via Illumina MiSeq sequencing clarified that the biohydrogen process in the two-stage systems functioned not only for biohydrogen production, but also for the degradation of potential inhibitors. The higher distribution of the detoxification family Clostridiaceae, Bacillaceae, and Pseudomonadaceae was found in the biohydrogen process. In addition, a higher distribution of acetate-oxidizing bacteria (Spirochaetaceae) was observed in the biomethane process of the two-stage systems, revealing improved acetogenesis accompanied with an efficient conversion of acetate.Biohythane production could be a promising process for the recovery of energy and degradation of organic compounds from hydrothermal liquefied biomass. The two-stage process not only contributed to the improved quality of the gas fuels but also strengthened the biotransformation process, which resulted from the function of detoxification during biohydrogen production and enhanced acetogenesis during biomethane production.

Biohydrogen Production and Quantitative Determination of Monosaccharide Production Using Hyperthermophilic Anaerobic Fermentation of Corn Stover

Bioconversion of corn stover hydrolysate to ethanol by a recombinant yeast strain

Biological hydrogen production from corn stover by moderately thermophile Thermoanaerobacterium thermosaccharolyticum W16

Bioaugmentation with Ruminiclostridium Thermocellum M3 to Enhance Thermophilic Hydrogen Production from Agricultural Solid Waste

Biohydrogen production from lignocellulosic hydrolysate: Unveiling the synergistic impact of substrate concentration and furfural inhibition

Enzymatic Saccharification of Cornstalk by Onsite Cellulases Produced by Trichoderma Viride for Enhanced Biohydrogen Production

Enhanced Cellulosic Hydrogen Production From Lime-Treated Cornstalk Wastes Using Thermophilic Anaerobic Microflora

Unraveling Hydrogen Production Potential by Glucose and Xylose Co‐fermentation of Thermoanaerobacterium Thermosaccharolyticum W16 and Its Metabolisms Through Transcriptomic Sequencing

Acid hydrolysis of corn stover for biohydrogen production using Thermoanaerobacterium thermosaccharolyticum W16

Analysis of Bio-Hydrogen Production Capacity of the Cellulose Degradation by Cellulolyticum Sp.x_9 and Ethanoigenens Harbinense B_(49)

Thermophilic Hydrogen Production from Starch Wastewater Using Two-Phase Sequencing Batch Fermentation Coupled with UASB Methanogenic Effluent Recycling

Simultaneous Saccharification and Fermentation of Fungal Pretreated Cornstalk for Hydrogen Production Using Thermoanaerobacterium Thermosaccharolyticum W16.

Continuous Production of Biohythane from Hydrothermal Liquefied Cornstalk Biomass Via Two-Stage High-Rate Anaerobic Reactors

Consolidated bioprocessing performance of Thermoanaerobacterium thermosaccharolyticum M18 on fungal pretreated cornstalk for enhanced hydrogen production.

Efficient Hydrogen Production from Lignocellulosic Feedstocks by a Newly Isolated Thermophlic Thermoanaerobacterium Sp. Strain F6

Single-step bioconversion of lignocellulose to hydrogen using novel moderately thermophilic bacteria

Dark Fermentation of Xylose and Glucose Mix Using Isolated Thermoanaerobacterium Thermosaccharolyticum W16

Tow Steps Biohydrogen Production: Biomass Pretreatment and Fermentation

SIMULTANEOUS BIO-HYDROGEN PRODUCTION AND PRETREATED CORN STALK DEGRADATION BY A NEW CELLULOSE- DEGRADATION BACTERIUM

Direct hydrogen production from lignocellulose by the newly isolated Thermoanaerobacterium thermosaccharolyticum strain DD32

Bio-immobilization of Dark Fermentative Bacteria for Enhancing Continuous Hydrogen Production from Cornstalk Hydrolysate.