Abstract:Biohythane production via two-stage fermentation is a promising direction for sustainable energy recovery from lignocellulosic biomass. However, the utilization of lignocellulosic biomass suffers from specific natural recalcitrance. Hydrothermal liquefaction (HTL) is an emerging technology for the liquefaction of biomass, but there are still several challenges for the coupling of HTL and two-stage fermentation. One particular challenge is the limited efficiency of fermentation reactors at a high solid content of the treated feedstock. Another is the conversion of potential inhibitors during fermentation. Here, we report a novel strategy for the continuous production of biohythane from cornstalk through the integration of HTL and two-stage fermentation. Cornstalk was converted to solid and liquid via HTL, and the resulting liquid could be subsequently fed into the two-stage fermentation systems. The systems consisted of two typical high-rate reactors: an upflow anaerobic sludge blanket (UASB) and a packed bed reactor (PBR). The liquid could be efficiently converted into biohythane via the UASB and PBR with a high density of microbes at a high organic loading rate.Biohydrogen production decreased from 2.34 L/L/day in UASB (1.01 L/L/day in PBR) to 0 L/L/day as the organic loading rate (OLR) of the HTL liquid products increased to 16 g/L/day. The methane production rate achieved a value of 2.53 (UASB) and 2.54 L/L/day (PBR), respectively. The energy and carbon recovery of the integrated HTL and biohythane fermentation system reached up to 79.0 and 67.7%, respectively. The fermentation inhibitors, i.e., 5-hydroxymethyl furfural (41.4-41.9% of the initial quantity detected) and furfural (74.7-85.0% of the initial quantity detected), were degraded during hydrogen fermentation. Compared with single-stage fermentation, the methane process during two-stage fermentation had a more efficient methane production rate, acetogenesis, and COD removal. The microbial distribution via Illumina MiSeq sequencing clarified that the biohydrogen process in the two-stage systems functioned not only for biohydrogen production, but also for the degradation of potential inhibitors. The higher distribution of the detoxification family Clostridiaceae, Bacillaceae, and Pseudomonadaceae was found in the biohydrogen process. In addition, a higher distribution of acetate-oxidizing bacteria (Spirochaetaceae) was observed in the biomethane process of the two-stage systems, revealing improved acetogenesis accompanied with an efficient conversion of acetate.Biohythane production could be a promising process for the recovery of energy and degradation of organic compounds from hydrothermal liquefied biomass. The two-stage process not only contributed to the improved quality of the gas fuels but also strengthened the biotransformation process, which resulted from the function of detoxification during biohydrogen production and enhanced acetogenesis during biomethane production.

A pilot study of biohythane production from cornstalk via two-stage anaerobic fermentation

Bioconversion of corn stover hydrolysate to ethanol by a recombinant yeast strain

Technical Assessment of Bioenergy Recovery from Cotton Stalks Through Anaerobic Digestion Process and the Effects of Inexpensive Pre-Treatments

Continuous Production of Biohythane from Hydrothermal Liquefied Cornstalk Biomass Via Two-Stage High-Rate Anaerobic Reactors

Effects of Operating Parameters on Hydrogen Production from Raw Wet Steam-Exploded Cornstalk and Two-Stage Fermentation Potential for Biohythane Production

Fermentative Production of 2,3-butanediol from Corn Stover Hydrolysate

Towards Biohythane Production from Biomass: Influence of Operational Stage on Anaerobic Fermentation and Microbial Community

Enhanced the energy conversion of corn stalk via co-production of photo-fermentation biohydrogen and bioethanol

A techno-economic analysis of bio-gasoline production from corn stover via catalytic conversion

Super diluted mixture alkali (SDMA) pretreatment for cornstalk anaerobic Digestion: A green strategy for High-Solid biogas production

Enhanced Biohydrogen Production from Corn Stover by the Combination of Clostridium Cellulolyticum and Hydrogen Fermentation Bacteria

Biohydrogen Production and Quantitative Determination of Monosaccharide Production Using Hyperthermophilic Anaerobic Fermentation of Corn Stover

A two-stage anaerobic bioconversion of corn stover: Impact of pure bacterial pretreatment on methane production

Metagenomic Analysis of Bacterial, Archaeal and Fungal Diversity in Two-Stage Anaerobic Biodegradation for Production of Hydrogen and Methane from Corn Steep Liquor

Effective conversion of maize straw wastes into bio-hydrogen by two-stage process integrating H2 fermentation and MECs

Pilot Study on Production of Aviation Fuel from Catalytic Conversion of Corn Stover

Application of rumen microorganisms for enhanced anaerobic fermentation of corn stover

Development, kinetic analysis, and economic feasibility of different Corn Stover-driven biorefineries to produce biohydrogen, bioethanol, and biomethane: A comparative analysis

Rumen microbe fermentation of corn stalk to produce volatile fatty acids in a semi-continuous reactor

Archaeal and Bacterial Content in a Two-Stage Anaerobic System for Efficient Energy Production from Agricultural Wastes

Can digestate recirculation promote biohythane production from two-stage co-digestion of rice straw and pig manure?