Abstract:For the unbalance vibration of the rigid rotor system on active magnetic bearings (AMBs) supported high-speed motors in the full rotational speed range, a method based on the polarity switching tracking filter (PSTF) and the disturbance observer (DO) is proposed to achieve vibration suppression. To identify the synchronous unbalance vibration, a positive polarity tracking filter and a negative one are adopted before and after the rigid critical rotational speed range, respectively. The rigid critical rotational speed is in this range whose lower/upper limit is the negative/positive polarity switching frequency. Although the PSTF can effectively reduce the rotor vibration when it rotates at subcritical rotational speed range and supercritical range, the vibration increases evidently and even destabilize the system within the rigid critical rotational speed range. It means that the PSTF cannot suppress the rotor unbalance vibration in the full rotational speed range. However, this vibration during the rigid critical rotational speed range can be considered as a kind of disturbance and the DO is adopted to observe it, then the vibration identified is compensated in the control current to reduce the rotor unbalance vibration in the rigid critical rotational speed range. Therefore, the method based on the PSTF and the DO can suppress the unbalance vibration in the full rotational speed range. Finally, simulation and experiment results demonstrate that the method proposed can effectively suppresses the synchronous unbalance vibration of the AMBs-rigid rotor system in the full rotational speed range.

Harmonic Suppression for PMSM Applied to MSTMP Based on Virtual Even-Order Fractional Repetitive Controller

Harmonic Injection-Based Torque Ripple Reduction of PMSM with Improved DC-Link Voltage Utilization

A Novel Harmonic Current Control Method for Torque Ripple Reduction of SPMSM Considering DC-Link Voltage Limit

Negative Sequence Current Suppression of Dual Three-Phase Permanent Magnet Synchronous Machines Considering Inductance Asymmetry

Improved 2-Order Active Disturbance Rejection Control for PMSM

Torque Ripple Suppression Control for Dual Three-Phase Permanent-Magnet Synchronous Motor

Techniques to restrain harmonics of dual three-phase permanent magnet synchronous motor

Adaptive Torque Ripple Suppression Methods of Three-Phase PMSM During Single-Phase Open-Circuit Fault-Tolerant Operation

A Deadbeat Predictive Current Harmonics Suppression Method for IPMSM Based on Quasi Proportional Resonant Control

Novel Virtual-Finite-Control-Set-Based Model Predictive Torque Control of Five-Phase PMSM With Enhanced Third Harmonic Current Suppression

Combined FIR and Fractional-Order Repetitive Control for Harmonic Current Suppression of Magnetically Suspended Rotor System.

Generalized Active Disturbance Rejection With Reduced-Order Vector Resonant Control for PMSM Current Disturbances Suppression

Research on Radial Vibration Model and Low-Frequency Vibration Suppression Method in PMSM by Injecting Multiple Symmetric Harmonic Currents

Vibration Suppression for Magnetically Levitated High-Speed Motors Based on Polarity Switching Tracking Filter and Disturbance Observer

Harmonic Model and Remedy Strategy of Multiphase PM Motor under Open-Circuit Fault

Harmonic Current Suppression Method with Adaptive Filter for Permanent Magnet Synchronous Motor

Research on a Torque Ripple Suppression Method of Fuzzy Active Disturbance Rejection Control for a Permanent Magnet Synchronous Motor

High-Frequency Current Harmonic Analysis and Suppression in Dual Three-Phase PMSMs with Advanced Carrier Phase-Shift PWM

Harmonic Torque Suppression Methods for Single-Phase Open-Circuit Fault-Tolerant Operation of PMSM Considering Third Harmonic BEMF

The Suppression of Torque Sideband Harmonics above Switching Frequency in the Unbalanced Operation of 3-Module PMSM

Harmonic currents suppression in direct torque control of dual three-phase permanent magnet synchronous motor