Abstract:Foam stability is adversely affected by the drainage process in the liquid film, which has been a great challenge for CO 2 foam flooding in applications. The Gibbs-Marangoni effect, which is induced by the interfacial tension (IFT) gradient, provides a resisting force to the thinning of liquid films in foams under disturbance. Surfactants with higher interfacial elasticity enable rapid recovery to the equilibrium state, thereby improving the stability of the CO 2 foam film. However, there is a lack of mechanistic studies aimed at elucidating the correlation between the interfacial elasticity of surfactant monolayers and the molecular structure of surfactants. In this paper, molecular dynamics simulations were employed to investigate the impact of the headgroups and linking groups of sodium polyoxyethylene alkyl ether sulfate (AES), sodium dodecylbenzene sulfonate (SDBS), sodium dodecyl sulfate (SDS), sodium dodecyl sulfonate (SDSn), and sodium laurate (SLA) surfactants on the interfacial morphology, monolayer properties, and surfactant behaviors at the CO 2 –water interface under reservoir conditions. The results show that the capacity to enhance CO 2 foam stability follows the order AES > SDS > SDSn > SDBS > SLA, which is in good agreement with the available experiments. AES monolayers can reach the lowest IFT (∼0.2 mN/m) and the highest interfacial elasticity (30.4 mN/m). We show that the ethylene oxide groups (EO chains) can strongly interact with water molecules via hydrogen bonding and have affinity interactions with CO 2 molecules, which is beneficial to the hydrophilic-CO 2 -philic balance (HCB). SDS monolayers show the second-lowest IFT (3.1 mN/m) and second-highest interfacial elasticity (26.0 mN/m). The linking oxygen atom in SDS facilitates bond rotation and is favorable to film stability. The phenyl group makes SDBS molecules too rigid and has poor HCB, leading to low stability with high IFT (16.0 mN/m) and low interfacial elasticity (13.1 mN/m). SLA has the highest IFT (22.1 mN/m) and lowest interfacial elasticity (6.3 mN/m), and also presents strong aggregation behaviors at the interface owing to interactions between the carboxyl groups. The simulation method and the microscopic insights delivered here are of great significance in screening surfactants to improve CO 2 foam performance in oilfields.

Foam formation in aqueous-ethanol system triggered by the ABA triblock siloxane surfactant

Preparation and rheological properties of a stable aqueous foam system

Formation of Stable Aqueous Foams on the Ethanol Layer: Synergistic Stabilization of Fluorosurfactant and Polymers

Ethanol enhanced anionic surfactant solubility in CO2 and CO2 foam stability: MD simulation and experimental investigations

Experimental investigation on the spread of aqueous foam over ethanol surface

Molecular Dynamics Simulation of the Synergistic Effect of Alkali/Surfactant/Polymer on the Formation and Stabilization of Water-Based Foam Systems

Effect of mixed surfactants on foam stabilization: A molecular dynamics simulation

Synthesis of Branched Surfactant Via Ethoxylation of Oleic Acid Derivative and Its Surface Properties

Interfacial properties and foam performance of alpha olefin sulfonate and CO2 switchable aminopropyl methyl siloxane surfactant mixtures

Surface and aggregation behavior of butynediol tetraethoxylate-based trisiloxanes

Organic Foams Stabilized by Biphenyl-bridged Organosilica Particles.

Evaluation of the interfacial elasticity of surfactant monolayer at the CO 2 –water interface by molecular dynamics simulation: Screening surfactants to enhance the CO 2 foam stability

Synthesis and Properties of Multilayered Films Foams

Synergistic effects of mediated by different 1,2-epoxybutane addition numbers butoxylated alkyl block alcohol ethers and SDS in mixed systems

Ultra-stable Aqueous Foams with Multilayer Films Stabilized by 1-Dodecanol, Sodium Dodecyl Sulfonate and Polyvinyl Alcohol

Aggregation Behavior of Polyether Based Siloxane Surfactants in Aqueous Solutions: Effect of Alkyl Groups and Steric Hindrance.

Experimental Study on Foam Properties of Mixed Systems of Silicone and Hydrocarbon Surfactants

Stability mechanism of SiO2/SDS dispersion for foam flooding in hydrocarbon reservoirs: experimental research and molecular simulation

Synergistic Foaming And Surface Properties Of A Weakly Interacting Mixture Of Soy Glycinin And Biosurfactant Stevioside

Structure–Behavior–Property Relationship Study of Surfactants as Foam Stabilizers Explored by Experimental and Molecular Simulation Approaches

Synergistic Stabilization Mechanism of SiO 2 Nanoparticles and Anionic Surfactants during Foam Fracturing