Abstract:The dual-tracked deep-sea mining vehicles used for sea trials generally cannot meet the demands of large-scale manganese nodules production due to their inadequate load bearing and traction performance. Various seabed mining organizations have gradually started four-tracked mining vehicles as seabed traveling ore collection machines to meet the demand for enhanced tractive performance. A notable challenge encountered is the significant front-rear track effect observed when these vehicles navigate soft-cohesive sediments. Addressing this, our study introduces a novel design concept that involves setting the grouser heights with a deviation between the front and rear tracks, coupled with the development of a traction force-slip rate model inspired by this innovative approach. This model facilitates an in-depth analysis of the front-rear track effect, including phenomena such as deep sinkage and an increase in pitch angle experienced by vehicles on soft-cohesive terrains. It is calculated that the front and rear grouser deviation height of only 2 cm can improve the traction force by 21%. Utilizing the multi-body dynamics (MBD) method, we validated the effectiveness of this grouser height adjustment in mitigating front-rear track effects, demonstrating its potential to reduce sinkage by at least 30 mm and pitch angle by at least 0.3 degrees, thereby guiding the optimization strategy. Finally, through optimization simulation, we present optimized track structural parameter sets suitable for three types of seabed pavement, concluding that for soft silty soil, saturated high cohesive soil, and saturated soft sandy soil, the grouser deviation heights should be approximately 5.3, 4.1, and 2.0 cm, respectively. After applying the optimized track structural parameter sets, traction performance evaluation indexes, such as traction force and the traction force-disturbing area ratio, improved by at least 23.4% and 3.3%, respectively. Meanwhile, static sinkage was reduced by at least 21.4% across the three types of pavements.

Dynamic Simulation Analysis of Track Tension and the Influencing Factors of Deep-Sea Tracked Mining Vehicle

Three-dimensional Finite Element Simulation on Moving Load Induced Track Response over Stiffness-varied Base

Research on the shear stress and microscopic deformation mechanism of deep sea sediments under the action of tracked miner

Dynamic Analysis of Metro Train-Monolithic Bed Track System under Tunnel Differential Settlement

Multi-Body Dynamics Modeling and Straight-Line Travel Simulation of a Four-Tracked Deep-Sea Mining Vehicle on Flat Ground

Track shoe structure optimization of deep-sea mining vehicle based on new rheological calculation formulae of sediment

Technical Note: Three-dimensional analyses of dynamic responses of track-ground system subjected to a moving train load

Investigation of tracked mining vehicles' driving performance at varying travel speeds by experimental and numerical simulation

Parameter optimization and tractive performance evaluation of tracked miner

Analysis of traction performance of deep-sea tracked mining vehicles under different grouser pitch-to-height ratios and traveling speeds

DYNAMIC RESPONSE ANALYSIS OF TRACK SYSTEM AND UNDERGROUND RAILWAY TUNNEL IN SATURATED SOIL SUBJECTED TO A MOVING TRAIN LOAD

Dynamic Analysis of Support System of Permanent Magnet Traction Motors for High-Speed Trains

Numerical study on shear interaction between the track plate of deep-sea mining vehicle and the seafloor sediment based on CEL method

Understanding front-rear track effect of seabed mining vehicle and traction performance optimization

Multiparameter Numerical Investigation of Two Types of Moving Interactions Between the Deep-Sea Mining Vehicle Track Plate and Seabed Soil: Digging and Rotating Motions

Analysis of the thermo-hydro-mechanical coupled dynamic response of sediments under eccentric driving of deep-sea mining vehicle

Semi-Empirical Time-Dependent Parameter of Shear Strength for Traction Force between Deep-Sea Sediment and Tracked Miner

Research and Simulation of Kinematics and Dynamics of Tracked Support Equipment Based on Multi-Body Dynamics

Experimental Study on the Shear Characteristics of Deep‐Sea Sediments Based on a Mining Machine Walking Test Platform

Experimental Study of Dynamic Load Magnification Factor for Type I Track-Subgrade System

Dynamic analysis and simulations of a deep-sea floating mining vehicle multi-body system under real-world operating conditions