Non-linear frequency modulated thermal wave imaging for subsurface analysis

S.S. Banda,V.S. Ghali,G.T. Vesala,R. Mulaveesala

DOI: https://doi.org/10.1016/j.infrared.2024.105248

IF: 2.997

2024-02-26

Infrared Physics & Technology

Abstract:Thermographic analysis for subsurface non-destructive evaluation often encounters challenges in achieving better depth scanning and enhanced depth resolution. Usually, deeper depth analysis will be facilitated by the strength of the low-frequency components and the depth resolution on the frequency sweep of the stimulation, along with material properties in this active thermographic modality. Non-linear frequency modulation became prominent for subsurface analysis due to its ability to provide a band of frequencies with increased energy at low frequencies. This manuscript introduced novel Logarithmic frequency modulated stimulation for subsurface analysis and compared it with its well-established linear frequency counterpart. A quantitative analysis was performed using detectability and sizing of the defects. Experimental results demonstrate that the proposed modality offered an edge over the state of the art, as shown by the experimentation carried out over a carbon fibre-reinforced plastic specimen with embedded flat bottom holes.

optics,physics, applied,instruments & instrumentation