Abstract:In this work, experiment was conducted to examine the thermo-physical properties of an alternative refrigerant to HCFC-22 in the presence of polyol ester (POE). The new alternative refrigerant is a mixture of HFC-32/125/161, whose physical properties are similar to HCFC-22 but has a lower global warming potential (GWP) than that of R407C. POE is used as the tested lubricating oil in the experiment. The saturated vapor pressure data and vapor–liquid equilibrium data of nine different mass fractions of the new refrigerant and polyol ester (POE) in the temperature range of 253–323K were measured by single-phase cycle method. The experiment results showed that there was no stratification, no sediment generation in the liquid phase of the mixture, and the color of liquid phase of the mixture had no change in the equilibrium cell before and after the experiment with the POE concentration greater than 20% and the temperature higher than 258K; with POE concentration lower than 20% and temperature lower than 258K, stratification began to appear. Meanwhile, when POE and the refrigerant were miscible, the saturated pressure data of the mixture (HFC-32/125/161+POE) revealed that POE had a very small impact on saturated vapor pressure of the mixture (almost negligible) when POE was less than 10% of the mixture; POE has an obvious effect on the saturated vapor pressure of the mixture when there is more than 10% POE in the mixture, especially when the temperature is higher than 283.15K. Experimental data were correlated by Flory–Huggins model, Heil model, NRTL model and Wilson model. The results showed that to the average and maximum pressure deviation, the results were better with considering the effects of temperature on the energy parameters. Among the above models, the NRTL activity coefficient model was the best, the Heil and Wilson models followed and the Flory–Huggins model had the largest deviation from the experimental data.

Experimental evaluation of NIR spectroscopic characteristics of liquid R32, R1234yf and R454C refrigerants

Measurements of the isobaric heat capacity of R1234yf in liquid phase at temperatures from 305 K to 355 K and pressures up to 5 MPa

Investigating the Thermal-Hydraulic Performance of New Refrigerant Mixtures Through Numerical Simulation of Minichannel and Microchannel Evaporators

Investigation on the Vapor–Liquid Equilibrium for the Ternary Mixture HFC-32 + HFC-125 + HFC-161 at Temperatures from 265.15 K to 303.15 K

Vapor–liquid Equilibria of HFC‐161 + HFC‐32 + DMF Ternary Mixture for Low‐grade Heat Driven Absorption Refrigeration System

Experimental studies on a mixture of HFC-32/125/161 as an alternative refrigerant to HCFC-22 in the presence of polyol ester

Phase Behavior and Enthalpies of Binary Mixtures of R-1243zf with PAG 68, POE 85 and PEC4 Oils

Vapor–Liquid Equilibria for the Binary and Ternary Systems of Difluoromethane (R32), 1,1-Difluoroethane (r152a), and 2,3,3,3-Tetrafluoroprop-1-ene (R1234yf)

Phase Equilibria of Difluoromethane (R32), 1,1,1,2-Tetrafluoroethane (r134a), and Trans-1,3,3,3-tetrafluoro-1-propene (r1234ze(e)) Probed by Experimental Measurements and Monte Carlo Simulations

Condensation heat and mass transfer characteristics of low GWP zeotropic refrigerant mixture R1234yf/R32 inside a horizontal smooth tube: An experimental study and non-equilibrium film model development

Experimental Investigation on the Surface Tension of R1243zf with POE Lubricants from 283 K to 343 K

Vapor-liquid Equilibrium Measurements and Models for the Ternary Mixtures of R1234yf + R32 + R125 and R1234yf + R32 + CO2

Surface Tension and Liquid Viscosity of R32+R1234yf and R32+R1234ze

Viscosity Measurements and Modeling for R32 and Binary Mixture of R32/R1234yf

New Measurements of Vapor Liquid Equilibria of Binary Mixtures of R 1234 ze ( E ) and R 1234 yf with R 134 a or R 125

Experimental analysis of vapour compression refrigeration system using nano lubricant with refrigerant R-134a

Measurement and Correlation for the Viscosity of R1234yf/POE85 and R1234ze(E)/POE85 Solutions

Experimental study of falling film evaporation of refrigerants, R32, R1234yf, R410A, R452B and R454B on horizontal tubes

Thermodynamic Investigation and Comparison of Absorption Cycles Using Hydrofluoroolefins and Ionic Liquid

Vapor–Liquid Equilibrium of R1234yf/[HMIM][Tf2N] and R1234ze(E)/[HMIM][Tf2N] Working Pairs for the Absorption Refrigeration Cycle

Critical properties and vapor-liquid equilibrium of two near-azeotropic mixtures containing HFOs