Abstract:Nitrogen oxides (NOx) as the principal air pollutants are mainly from the combustion of fossil fuels. Oxy-fuel combustion is a promising clean coal technology, by which carbon dioxide (CO2) can be captured in large-scale and NOx emission can be reduced significantly. The formation of nitrogen dioxide (NO2) in oxy-fuel combustion exceeds that under traditional air condition. However, the specific studies on NO2 chemistry under oxy-fuel condition are still insufficient and the functional mechanisms of minerals and combustion atmosphere on NO2 reduction have yet to be fully understood. The objective of present study is to experimentally clarify the effects of combustion atmosphere and coal char on NO2 reduction in oxy-fuel combustion using a fixed-bed reactor. Experimental results showed that the decomposition of NO2 had a strong temperature dependence and the NO2 reduction rate showed a positive variation with temperature. The strength of catalytic activity in NO2 reduction to nitric oxide (NO) was Fe2O3 > MgO > CaO > Al2O3 > Na2CO3 > K2CO3 > SiO2. In addition, the increased concentrations of carbon monoxide (CO) and CO2 could promote the reduction of NO2, while the low content of CO2 only established a slight impact on NO2 reduction. However, the increase of oxygen (O2) concentration displayed an inhibition effect on NO2 reduction to a certain extent. The variation of atmosphere in oxy-fuel combustion generated a substantial influence on the creation and reduction of NO2. The char prepared in lower temperature exhibited a higher promotion effect on the consumption of NO2. Higher contents of fixed carbon and basic oxides had more obvious stimulation effects on NO2 reduction. Fixed carbon had a superior activity in NO2 reduction than ash. The kinetic analysis indicated that high content of CO and the presence of char could reduce the apparent activation energy of NO2 reduction. The present study can be helpful to improve the understanding of NO2 chemistry in oxy-fuel combustion.

Comparative study of carbon-deNO process by different sewage sludge chars

Low temperature catalytic oxidation of NO over sludge char under different pyrolysis activation conditions

Optimization of nitrogen-doped sludge char preparation and mechanism study for catalytic oxidation of NO at room temperature

Influences of Water Vapor and CO2 on NOx Removal by Plasma-facilitated Selective Catalytic Reduction

Intensification of NO x Conversion over Activated Coke by Ozone Oxidation for Sintering Flue Gas at Low Temperatures

Investigations of NO reduction by coal-based activated carbon with KOH activation: Performance and mechanism

Pore structure of sludge char and simultaneously NO removal characteristics in the treated flue gas from Ca-L

A comprehensive study of char reaction kinetics: Does CO always promote NO reduction on char surface?

Experimental study on effects of combustion atmosphere and coal char on NO 2 reduction under oxy-fuel condition

Experimental and Modeling Study of the Effect of CH(4) and Pulverized Coal on Selective Non-Catalytic Reduction Process.

Study on the mechanism of iron-rich coal gasification slag on NO conversion in high temperature flue gas of cement kiln

Catalytic Oxidation of NO on Activated Carbons

Lab- and pilot-scale wet scrubber study on the redox-mediated simultaneous removal of NO and SO2 using a CaCO3-based slurry with KI as a redox catalyst

Comparative study on the physicochemical properties and de-NOx performance of waste bamboo-derived low-temperature NH3-SCR catalysts

Nitric Oxide Emissions During the Evolution of Gasified Char in the Reduction Layer During a Grate-Fired Process

Investigation of modified carbon-based catalyst on low-temperature selective reduction of flue gas denitration performance

Effect of Nitriding Treatment on Char Reducing Nitric Oxide at High Temperature

Achieving an ultralow emission of nitrogen oxides by using activated carbon with hydrophobic modification

Experimental Study on the Removal of SO3 from Coal-Fired Flue Gas by Alkaline Sorbent

Performance of transition metal (Cu, Fe and Co) modified SCR catalysts for simultaneous removal of NO and volatile organic compounds (VOCs) from coal-fired power plant flue gas

Experimental and modeling investigation on char combustion and char-nitrogen evolution characteristics under different conditions