Abstract:A pressurized chemical-looping combustion combined cycle (PCLC) system is proposed for solid fuels combustion with potential high system efficiency, improving the fuel conversion and lowering the cost for CO, sequestration. In this Study pressurized CLC of coal With Companhia Valedo Rio Doce (CVRD) iron Ore was investigated in a laboratory fixed bed reactor focusing on cyclic performance lice. CVRD iron Ore particles were exposed alternately for 20 cycles to reduction by 0.4 g of Chinese Xuzhou bituminous coal gasified with 87% stream/N-2 mixture and oxidation with 5% O-2 in N-2 at 970 degrees C at atmospheric pressure (0.1 MPa) and a typical elevated pressure of 0.5 MPa. With increasing number of redox cycles, more pyrolysis gases are oxidized by the oxygen carrier. At elevated pressure, the chat gasification is intensified with negligible gasification intermediate products released. The CO2 fraction increases from 80% to approximate 90% after 10 cycles at atmospheric pressure. At elevated pressures, the average CO2 fraction stabilizes at 95.75%, approximate to the equilibrium value. The carbon conversion at 0.1 MPa and 0.5 MPa is 76.48 and 84.65%, respectively, and maintains approximately the same during the cycles because excessive Steam gasification agent used in this study. The oxygen carrier conversion determined from the oxygen in ass balance verifies that reduction level increases With the Cycle number. The physical and chemical properties of oxygen carrier particles were characterized. X-ray diffraction (XRD) analysis verifies the extent of reduction level increases with cycles, No detectable formation of compound of iron oxide and coal ash was observed. Scanning electron microscope (SEM) analyses show that the iron Ore particles become porous and that more pores formed with cycles. Agglomeration of particles was not observed in all experiments at both pressures. X-ray spectroscopy (EDX) analysis show an increasing amount of coal ash Oil the Oxygen carrier particles With increasing numbers of cycles. Pore size analyses Show that the oxygen carrier particles maintained mesopores for both atmospheric and elevated pressure. The increase of both surface area and pore volume illustrates that the particles become more porous with redox cycles. This study Show that pressurized CLC of coal is promising and a low-cost iron ore-based oxygen carrier may be suitable for pressurized CLC of coal.

Technical and life cycle performance comparison between petroleum coke chemical looping combustion and oxy-combustion combining with advanced steam cycles for power generation processes

Modeling, optimization, and system evaluation of ammonia production processes by direct chemical looping of petroleum coke/coal

Analysis of Thermally Coupled Chemical Looping Combustion-Based Power Plants with Carbon Capture

Power Generation from Coke Oven Gas Using Chemical Looping Combustion: Thermodynamic Simulation

Pressurized Chemical-Looping Combustion of Chinese Bituminous Coal: Cyclic Performance and Characterization of Iron Ore-Based Oxygen Carrier

Concept design, technical performance, and GHG emissions analysis of petroleum coke direct chemical looping hydrogen highly integrated with gasification for methanol production process

Life cycle energy-economy-environmental evaluation of coal-based CLC power plant vs. IGCC, USC and oxy-combustion power plants with/without CO<sub>2</sub> capture

Conversion characteristics of lignite and petroleum coke in chemical looping combustion coupled with an annular carbon stripper

Technical Economic and Environmental Analysis of Chemical Looping Versus Oxyfuel Combustion for NGCC Power Plant

Life cycle energy-economy-environmental evaluation of coal-based CLC power plant vs. IGCC, USC and oxy-combustion power plants with/without CO2 capture

Energy consumption and CO2 emissions of petroleum coke-to-methanol with/without carbon capture using process modeling and life cycle analysis

Use of Fe2O3-Containing Industrial Wastes As the Oxygen Carrier for Chemical-Looping Combustion of Coal: Effects of Pressure and Cycles

Parameter optimization and exergy efficiency analysis of petroleum coke-to-hydrogen by chemical looping water splitting process with CO 2 capture and self-heating

Energy and exergy analysis of chemical looping combustion technology and comparison with pre-combustion and oxy-fuel combustion technologies for CO2 capture

Pinch combined with exergy analysis for heat exchange network and techno-economic evaluation of coal chemical looping combustion power plant with CO<sub>2</sub> capture

Energy and Exergy Analysis of Power Generation Systems with Chemical Looping Combustion of Coal

Chemical Looping Combustion of Coke Oven Gas by Using Fe2O3/CuO with MgAl2O4 As Oxygen Carrier

Comparison of Metallic Oxide, Natural Ore and Synthetic Oxygen Carrier in Chemical Looping Combustion Process

Process simulation of Chemical Looping Combustion using ASPEN plus for a mixture of biomass and coal with various oxygen carriers

Concept Design, Parameter Analysis, and Thermodynamic Evaluation of a Novel Integrated Gasification Chemical-Looping Combustion Combined Cycle Power Generation System

Pressurized chemical-looping combustion of coal with an iron ore-based oxygen carrier