Abstract:Abstract Introduction Skin substitutes provide unique utility for the management of thermal injuries over the last 20 years and have evolved into over 75 available technologies today. They are used for patients where insufficient autograft was lacking. Despite demonstrated long term safety and efficacy, use of skin substitutes remains controversial with respect to health economic metrics, including length of stay (LOS), complications, timing of application, number and types of procedures, resource use, and depth of burn. Clinical studies investigate skin substitute use in smaller burns (~20% TBSA) or in some anatomical regions (face, neck), but few address impact within a large national registry inclusive of all burn sizes and locations. The goals of this study were to investigate skin substitutes use for burns over the last 13 years and to elucidate where skin substitutes have the most utility in the burn care continuum. Methods NBR data from 2008-2021 were analyzed (n = 388,775 patients). Surviving patients treated with a dermal regenerative graft during their care were identified via ICD-9 and ICD-10 codes (n=41,785 patients) and to show all surviving patients only and eliminating patients with data missing (n=32,428). Metrics including patient demographics (age, sex, race, comorbidities, burn degree, burn location/area) and outcome measurements (length of stay (LOS), total body surface area (TBSA) (2nd, 3rd, and combined), complications, resources, days in the ICU, number of procedures, number of excisional and non-excisional debridements). Additional analyses included determining the percentage of 2nd and 3rd degree burns (normalizing against total) and normalizing patients’ LOS per TBSA and investigating differences between skin substitute patients where their treatment was applied early (less than or equal to 7 days) or late (greater than or equal to 8 days). Results Patients with the majority of their burn being 3rd degree and their skin substitutes applied within the first 7 days of admission, particularly for 10-20% TBSA and 20-40% TBSA were associated with a significantly lower LOS/TBSA compared to the same patients who received their skin substitute 8 days or later. Skin substitute use was associated with LOS/TBSA over 1.5 for all size burns when applied early and over 1.7 when applied late (Fig1). Conclusions This study illustrates the first analysis of the ABA NBR investigating skin substitute use in burns, including high TBSA burns. Previous studies have limitations and overestimation of the traditional rule-of-thumb of LOS/TBSA near 1, including confounding variables such as age, complications, inhalation injury, and depth of burn. This study also shows that the care algorithm should be considered in outcome measures; future analysis will investigate this patient cohort to further understand the clinical and health economic implications of skin substitute use for burns. Applicability of Research to Practice Knowing when to apply a skin substitute

534 Retrospective Study Comparing Acute Healing Outcomes of Two Epidermal Skin Substitutes in Paediatric Partial-Thickness Burns

Evaluation of Bacterial Cellulose Dressing Versus Vaseline Gauze in Partial Thickness Burn Wounds and Skin Graft Donor Sites: A Two-Center Randomized Controlled Clinical Study

Acute Healing Outcomes in Paediatric Partial Thickness Burns Using Epiprotect® and Biobrane®: A Retrospective Comparative Study

Comparative effectiveness of Biobrane®, RECELL® Autologous skin Cell suspension and Silver dressings in partial thickness paediatric burns: BRACS randomised trial protocol

Evaluation of EpiProtect® microbial cellulose burns dressings in young children

A Comparative Clinical Study of Skin Substitutes and Silver and Paraffin Gauze Dressings

A Pilot Randomised Controlled Trial Evaluating a Regenerative Epithelial Suspension for Medium-Size Partial-Thickness Burns in Children: The BRACS Trial

Factors influencing surgical care and outcome of pediatric burn injuries and the use of synthetic skin substitutes

87 Impact of Skin Substitute Use for Burns: An Analysis of the ABA National Burn Repository

Real-world data analysis of bilayered living cellular construct and fetal bovine collagen dressing treatment for pressure injuries: a comparative effectiveness study

90 Outcomes of Minimally Invasive Excision with Epidermal Autografting in Pediatric Partial Thickness Burns

Retrospective Evaluation of Progenitor Biological Bandage Use: A Complementary and Safe Therapeutic Management Option for Prevention of Hypertrophic Scarring in Pediatric Burn Care

BACTERIAL NANOCELLULOSE DRESSING COMPARED WITH HYDROCOLLOID DRESSING FOR THE TREATMENT OF PARTIAL-THICKNESS SECOND-DEGREE BURNS: A PROSPECTIVE, RANDOMIZED CONTROL TRIAL

Comparative results of autologous skin cell suspension combined with a contact layer dressing versus autologous skin cell suspension and a poly-lactic acid dressing in larger total body surface burns

The Effectiveness of Silver-containing Hydrofiber Dressing Compared With Topical Silver Sulfadiazine Cream in Pediatric Patients With Deep Partial-Thickness Burns: A Retrospective Review

Xeroform Stick-Down Dressing

Outcomes and Influencing Factors

607 Cultured Epidermal Autografts versus Spray Keratinocytes for Massive Burns—a Cost Effectiveness Analysis

A recombinant human collagen hydrogel for the treatment of partial-thickness burns: A prospective, self-controlled clinical study

Outcomes of dermal substitutes in burns and burn scar reconstruction: A systematic review and meta-analysis

725 Case Series: New Porcine Placental ECM for Burn Injuries