Abstract:An in situ 3D reconstruction methodology based on scanning transmission electron microscopy is presented to characterize the morphology and composition of bimetallic nanoparticle catalysts, requiring no tilting and using a low electron dose. PtNi nanoparticles are found to lose their Pt‐rich surface regions on heating and become increasingly homogenous, which is correlated with a decrease in the oxygen reduction activity. Tailoring nanoparticles' composition and morphology is of particular interest for improving their performance for catalysis. A challenge of this approach is that the nanoparticles' optimized initial structure often changes during use. Visualizing the three dimensional (3D) structural transformation in situ is therefore critical, but often prohibitively difficult experimentally. Although electron tomography provides opportunities for 3D imaging, restrictions in the tilt range of in situ holders together with electron dose considerations limit the possibilities for in situ electron tomography studies. Here, an in situ 3D imaging methodology is presented using single particle reconstruction (SPR) that allows 3D reconstruction of nanoparticles with controlled electron dose and without tilting the microscope stage. This in situ SPR methodology is employed to investigate the restructuring and elemental redistribution within a population of PtNi nanoparticles at elevated temperatures. The atomic structure of PtNi is further examined and a heat‐induced transition is found from a disordered to an ordered phase. Changes in structure and elemental distribution are linked to a loss of catalytic activity in the oxygen reduction reaction. The in situ SPR methodology employed here can be extended to a wide range of in situ studies employing not only heating, but gaseous, aqueous, or electrochemical environments to reveal in‐operando nanoparticle evolution in 3D.

Revealing high temperature stability of platinum nanocatalysts deposited on graphene oxide by in-situ TEM

Thermal stability, ripening dynamics and coalescing microstructures of reduced graphene oxide-based platinum nanocatalysts: An in-situ TEM study

Embedding Ultrafine and High-Content Pt Nanoparticles at Ceria Surface for Enhanced Thermal Stability.

In situ atomic-scale studies of thermal stability and surface reconstruction of ZnO nanowires based Pd nanocatalysts

Atomic Level Understanding of the Structural Stability and Catalytic Activity of Nanoporous Gold/Titania Cluster Inverse Catalysts at Ambient and High Temperatures

Extraordinary Thermal Stability and Sinter Resistance of Sub-2 nm Platinum Nanoparticles Anchored to a Carbon Support by Selenium

In situ study of the thermal stability of supported Pt nanoparticles and their stabilization via atomic layer deposition overcoating

In-situ Formed Stable Pt Nanoclusters on Ceria-Zirconia Solid Solutions Induced by Hydrothermal Aging for Efficient Low-Temperature CO Oxidation

In-Situ High-Resolution Transmission Electron Microscopy Investigation of Overheating of Cu Nanoparticles

In situ synthesis of highly-active Pt nanoclusters via thermal decomposition for high-temperature catalytic reactions

Revealing Surface Elemental Composition and Dynamic Processes Involved in Facet-Dependent Oxidation of Pt3Co Nanoparticles Via in Situ Transmission Electron Microscopy

Two-dimensional crystalline platinum oxide

An investigation on the structure properties of platinum nanoparticle deposition on graphene sheets by gamma-ray irradiation: a study of methanol electro-oxidation by synthesis catalyst

Enhanced Stability of Immobilized Platinum Nanoparticles through Nitrogen Heteroatoms on Doped Carbon Supports

Stabilization of Exposed Metal Nanocrystals in High‐Temperature Heterogeneous Catalysis

Highly Active Platinum Nanoparticles on Graphene Nanosheets with a Significant Improvement in Stability and CO Tolerance

In-situ observation of defects evolution of graphene nanoflakes in Pt/C catalyst for boosting ORR performance

Nanostructured TiO2 Support Effect on Hydrothermal Stability of Platinum Based Catalysts

In Situ Single Particle Reconstruction Reveals 3D Evolution of PtNi Nanocatalysts During Heating

Getting Insights into the Temperature-Specific Active Sites on Platinum Nanoparticles for CO Oxidation: A Combined in Situ Spectroscopic and Ab Initio Density Functional Theory Study

A Hydrothermally Stable Single-Atom Catalyst of Pt Supported on High-Entropy Oxide/Al 2 O 3 : Structural Optimization and Enhanced Catalytic Activity