Bimetallic Rex-Ru/C catalyst for fatty acid esters to diesel-range alkanes under low temperature

Jiaping Zhao,Xincheng Cao,Peng Liu,Feng Long,Shiyu Wu,Junming Xu,Jianchun Jiang

DOI: https://doi.org/10.1080/15435075.2024.2430444

IF: 3.206

2024-11-27

International Journal of Green Energy

Abstract:The hydrogenation of bio-based oil into biodiesel is a key strategy in reducing reliance on fossil fuels. However, efficient catalysts are needed to enable low-temperature hydrogenation reactions due to the current high-temperature requirement for bio-based oil hydrogenation. Here, bimetallic catalysts Re x -Ru/C for low-temperature hydrogenation of bio-based oils were prepared. The presence of Re oxides (ReOx) in the catalyst enhances the abundance of weak and medium acid sites, thereby facilitating the adsorption of H 2 . The DFT calculation shows the introduction of Re also improved the adsorption capacity of the catalyst for fatty acid methyl ester and H2. The Re 0.25 -Ru/C catalyst exhibits superior conversion, selectivity, and recyclability at low temperatures compared to the previously reported catalysts, achieving 100% conversion of methyl stearate with 100% selectivity toward n -heptadecane (C 17 ) and n -octadecane (C 18 ) (reaction conditions: 150°C, 4 h, 2.5 MPa H 2 ). Moreover, the catalyst also shows excellent hydrogenation activity toward various fatty acids or esters, including methyl palmitate, stearic acid, and palmitate at low temperatures. The Re 0.25 -Ru/C catalyst showed consistent recycling performance over 9 cycles. The decline in catalytic performance of the catalyst was primarily caused by a reduction in ReOx content, resulting in a decrease in acid site concentration. Consequently, there was reduced adsorption of H 2 and oil on the catalyst.

energy & fuels,thermodynamics,green & sustainable science & technology