Abstract:A combined steady-state and transient approach is employed to investigate the corrosion behavior of X80 pipeline steel in carbon dioxide-saturated brines. Continuous bubbling of carbon dioxide into a test vessel with 1 liter capacity is performed to simulate the flowing condition. The measurement of time-dependent open-circuit potential, polarization resistance, and electrochemical impedance spectroscopy (EIS) is conducted to interpret the evolution of dissolution processes at the corroding interface. Three distinguishing stages are observed at a temperature of 60 °C during a whole exposure of 144 h. Analyses mainly based on the consecutive mechanism show that after the first stage of the active-adsorption state, the anodic reaction is significantly retarded by the accumulation of (FeOH)ads on the iron surface, causing a sharp increase in the polarization resistance and the open-circuit potential, as well as the disappearance of the inductive loop in EIS. At the third stage, the formation of the corrosion product layer similarly reduces both the anodic and cathodic reactions, which arouses a linear increase in the polarization resistance with time and a capacitive loop in EIS but changes the open-circuit potential slightly. An increase in salinity in this study reduces the polarization resistance and enhances iron dissolution by promoting the formation and relaxation of (FeOH)ads; however, it brings little change to the developing time of the three stages obviously. At a low temperature of 20 °C, a protective product layer is not observed in carbon dioxide-saturated brine, and the dissolution of iron is mainly under activation control during the whole exposure. A notable enlarged polarization resistance and different interfacial processes are observed in an alkaline solution compared with those in acidic environments, which is deduced to be resulted from an impedance in the relaxation of (FeOH)ads by increasing pH. The observations in this study support well that the iron dissolution reaction at the initial stage exposed in carbon dioxide aqueous environments is dominant by water adsorption on the iron surface, and further investigation should be performed on the role that carbon dioxide plays in the evolution of corrosion products and the formation of a protective film on the steel surface by taking into account local water chemistry.

The Corrosion Behavior of X100 Pipeline Steel in a Sodium Chloride Solution Containing Magnesium and Calcium

Effect of Ca2+ and Mg2+ on Corrosion and Scaling of Galvanized Steel Pipe in Simulated Geothermal Water

Corrosion Behaviors of X80 Pipeline Steel in Different Simulated Alkaline Soil Solution

Pitting corrosion of X80 pipeline steel in 0.5 mol/l NaHCO3+0.02 mol/l NaCl solution

Effect of FexCayCO3 and CaCO3 Scales on the CO2 Corrosion of Mild Steel

Experimental Investigation on Corrosion Behavior of X80 Pipeline Steel under Carbon Dioxide Aqueous Conditions

CO2 corrosion behavior of simulated heat-affected zones for X80 pipeline steel

Corrosion Behavior of X80 Pipeline Steel in Alkaline Sand Soil with Saturated Water

Electrochemical Corrosion Behavior of X80 Pipeline Steel in Simulated Medium of Saline-alkali Soil

Internal localized corrosion of X100 pipeline steel under simulated flow conditions

Effects of the Concentration of Calcium Ions on the Corrosion Behavior of X80 Steel

The influence of calcium ions on corrosion of mild carbon steel in oilfield produced water

Corrosion Resistance of X80 Pipeline Steel in Simulated Solution of Seaside Saline-Alkali Soil

Corrosion Inhibition Properties of Corrosion Inhibitors to under-Deposit Corrosion of X65 Steel in CO2 Corrosion Conditions

Electrochemical Study on the Macro-Cell Corrosion of Pipeline Steel Partially Covered by Different Kinds of Mineral Deposits

Effect of Stress on Corrosion Behaviors of X70 Steel in NaHCO3 Solution

Synergistic Effect between Chloride and Sulfate Reducing Bacteria in Corrosion Inhibition of X100 Pipeline Steel in Marine Environment

Experimental and Numerical Investigation into the Corrosion Performance of X100 Pipeline Steel under a Different Flow Rate in CO2-saturated Produced Water

The effect of CaCO 3 deposit on corrosion of NaCl - Alkali/ surfactant/ polymer produced water pipeline

Effect of Microstructures on Corrosion of X80 Pipeline Steel in an Alkaline Soil

Corrosion behavior of X80 pipeline steel local defect pits under static liquid film