Abstract:Microbial fuel cell (MFC) is a promising emerging technology in which waste can be converted into energy, hydrogen and many other valuable products. Proton exchange membrane (PEM) contributes a significant portion (around 50%) of the overall cost of MFC. The current study focuses on synthesizing low-cost PEM using biochar produced by biomass pyrolysis at 400 °C. The Pristine biochar (PB) obtained by pyrolysis was sulphonated to improve the desirable properties required for the preparation of PEM. Brunauer-Emmet-Teller (BET) measurements show a considerable improvement in surface area per unit weight and decreased sulphonated biochar (SB) micropore size. FTIR analysis shows that the peak position is at 1169 cm −1 , which indicates the presence of the sulphonyl group ( ) in the SB. The presence of the group demonstrated that the sulphonation of biochar by sulphuric acid was done successfully. A comparison of proton conductivity between SB and PB was determined by Nyquist plot using Zsimp Win 3.21 software and the data taken from electrochemical impedance spectroscopy (EIS) measurements. A large improvement in the proton conductivity of SB (0.135 S cm −1 ) was observed compared to that of PB (0.0204 S cm −1 ). The morphological structure of PB and SB was studied using the scanning electron microscope (SEM). The SEM results showed more even pore distribution and the presence of pores and crevices on the SB than PB, which promotes better proton transfer. EDX results show the presence of sulphur in SB, which confirms the results of FTIR. Polyvinyl alcohol was used as a binder for the membrane preparation. The maximum power density of the MFC with SB-based PEM was found to be 5.6 mWcm −1 . The estimated cost of the material was found to be 17 times cheaper than Nafion. This study demonstrated that biochar-based PEM can drastically lower the MFC's overall cost.

Development of cost-effective proton exchange membrane using agro waste-based biochar for application in microbial fuel cell (MFC)

Doped polymethyl methacrylate (PMMA) as proton exchange membrane for microbial fuel cell

Vermiculite nanosheet augmented novel proton exchange membrane for microbial fuel cell

Goethite supplemented natural clay ceramic as an alternative proton exchange membrane and its application in microbial fuel cell

Performance evaluation of microbial fuel cell using a radiation synthesized low density polyethylene-grafted-poly (glycidyl methacrylate-co-vinyl acetate) as a proton exchange membrane

Improving MFC efficiency in power generation and COD removal by using protic ionic liquid in MWCNT-CS-2-aminothiazole-SO 3 H nanoparticle-infused sulfonated PES

Enhanced performance study of microbial fuel cell using waste biomass-derived carbon electrode

Electrochemical Performance of Microbial Fuel Cells Based on Disulfonated Poly(Arylene Ether Sulfone) Membranes

Effectiveness of Direct Sulfonated Polysulfone in Dual Chamber Microbial Fuel Cells Based Dewatered Sludge for Power Generation

Eco-friendly, low-cost, and antibacterial PEM boosts microbial fuel cell performance: Power generation and wastewater treatment

Next‐Generation Proton‐Exchange Membranes in Microbial Fuel Cells: Overcoming Nafion's Limitations

Microfiltration Membrane Performance in Two-Chamber Microbial Fuel Cells

Medium-chain-length poly-3-hydroxyalkanoates-carbon nanotubes composite as proton exchange membrane in microbial fuel cell

Application of biochar in microbial fuel cells: Characteristic performances, electron-transfer mechanism, and environmental and economic assessments

Development of a Novel Composite Polymer Electrolyte Membrane for Application as a Separator in a Dual Chamber Microbial Fuel Cell

Review on Waste Biomass Valorization and Power Management Systems for Microbial Fuel Cell Application

Evaluating the efficiency of a mixed culture biofilm for the treatment of black liquor and molasses in a mediator-less microbial fuel cell

Optimization preparation of composite membranes as proton exchange membrane for gaseous acetone fed microbial fuel cells

Study on the performance of biochar prepared from walnut shell and traditional graphene electrode plate in the treatment of domestic sewage in microbial fuel cells

Catalytic membrane cathode integrated in a proton exchange membrane-free microbial fuel cell for coking wastewater treatment

Use of Carbon Mesh Anodes and the Effect of Different Pretreatment Methods on Power Production in Microbial Fuel Cells.