Abstract:Photocatalytic self-Fenton systems by coupling photocatalysis and Fenton technology overcome the limitations of conventional Fenton reactions by in situ generation and activation of H2O2. However, a considerable amount of iron sludge is still produced. In this study, we developed a novel self-cycled photocatalytic Fenton process for the degradation of organic pollutants via an iron-nickel foam-supported MnS nanosheet (MnS/INF). Without the external addition of both H2O2 and ferrous ions, the MnS/INF 3D Z-scheme heterojunction exhibited an extremely high H2O2 production rate of 25.4 mM h-1 g-1 under visible light irradiation, which is 2-119 times higher than those of the reported photocatalytic self-Fenton systems in the literature. The photogenerated electrons of MnS/INF can participate in the Fe2+/Fe3+ cycle process to promote H2O2 activation, significantly enhancing the catalytic performance owing to the formation of a 3D Z-scheme heterojunction. DFT calculations indicate that MnS/INF can lower the energy barrier of *OOH formation and result in an enhanced photocatalytic activity of H2O2 production. Magnetic MnS/INF was easily recycled, remained very stable, and mitigated the extra undesirable Fe-containing sludge and only little iron sludge (0.43 mmol L-1) was produced after nine cycles of reuse. Furthermore, large (100 cm2) MnS/INF was used for an unassisted solar-driven in situ photocatalytic H2O2 production and rapid degradation of RhB with requirements of only water, oxygen and sunlight. In addition, MnS/INF also exhibited good performance in real wastewater containing fluoronitrobenzene from a factory (initial COD 2310 mg L-1) and wastewater from a sewage treatment station (initial COD 106 mg L-1). This work may provide leverage to minimize iron sludge from the Fenton reaction's source. The self-cycled photocatalytic Fenton system rapidly degrades organic pollutants containing real wastewater.

Sustainable disposal of Fenton sludge and enhanced organics degradation based on dissimilatory iron reduction in the hydrolytic acidification process

Enhanced dewatering extent of sludge by Fe3O4-driven heterogeneous Fenton

Enhancing anaerobic digestion of actual papermaking wastewater with addition of Fenton sludge

Influence of cell lysis by Fenton oxidation on cryptic growth in sequencing batch reactor (SBR): Implication of reducing sludge source discharge

Treatment of Electroplating Wastewater Containing Nickel by Fenton Oxidation-Ferrite Process

Perspectives on sustainable process control optimization through reusability of non-regenerated Fenton sludge in landfill leachate treatment

Enhancing sludge methanogenesis with changed micro-environment of anaerobic microorganisms by Fenton iron mud

Application of a Novel Strategy—advanced Fenton-chemical Precipitation to the Treatment of Strong Stability Chelated Heavy Metal Containing Wastewater

Treatment of industrial ferric sludge through a facile acid-assisted hydrothermal reaction: Focusing on dry mass reduction and hydrochar recyclability performance

Research on deeply modified Fenton sludge for the selective catalytic reduction of NO x : Promotion mechanism of acidification reorganization

Effect of Iron-Carbon Micro-Electrolysis-Fenton on the Dewatering Performance of Sludge

Promoting short-chain fatty acids production from sewage sludge via acidogenic fermentation: Optimized operation factors and iron-based persulfate activation system

Sludge dewaterability improvement with microbial fuel cell powered electro-Fenton system (MFCPEFs): Performance and mechanisms

Optimization of Fenton treatment process for degradation of refractory organics in pre-coagulated leachate membrane concentrates.

Enhancement of waste-activated sludge dewaterability using combined Fenton pre-oxidation and flocculation process

Anodic Fenton Process Assisted by a Microbial Fuel Cell for Enhanced Degradation of Organic Pollutants.

Synchronous In-Situ Sludge Reduction and Enhanced Denitrification Through Improving Electron Transfer During Endogenous Metabolisms with Fe(Ⅱ) Addition

Enhancement of nitrogen and phosphorus removal, sludge reduction and microbial community structure in an anaerobic/anoxic/oxic process coupled with composite ferrate solution disintegration

Self-cycled Photocatalytic Fenton System and Rapid Degradation of Organic Pollutants over Magnetic 3D MnS Nanosheet/iron-Nickel Foam

New methods for quantification of Fenton’s reagent addition based on aged sludge indicators to improve filterability

Sintering process of Fenton sludge-derived water treatment filler