Abstract:The electrochemical hydrogenation (ECH) of bio-mass derived compounds is an attractive alternative to traditional thermochemical hydrogenation (TCH) methods that are used in the U.S. chemical and petroleum industries to produce value-added fuels and chemicals. TCH uses high pressures and temperatures, along with an external source of hydrogen gas typically produced via methane reformation; these requirements make it an energy intensive process. ECH has the advantages of operating near ambient conditions and sourcing the participating hydrogen from the aqueous electrolyte solution, resulting in reduced energy costs and CO 2 emissions compared to TCH. The applied potential provides an additional parameter for controlling selectivity, which makes ECH more suitable to handle the wide chemical variability of biomass-derived feedstocks. Aromatic hydrocarbons are of interest as model compounds for lignocellulosic bio-oil [1]. The ECH of aromatic hydrocarbons proceeds with high faradaic efficiency (FE) at low overpotentials, however, the ECH turnover rate remains low at these potentials. There is no simple fix to this, as any increase in overpotential, to increase ECH rate, will reduce the reaction FE due to competition with the hydrogen evolution reaction (HER). In this work we address the need for a more fundamental understanding of ECH systems to promote high turnover rates at low overpotentials. Specifically for phenol TCH, it is well known that the hydrogenation is limited by the formation/addition of surface adsorbed hydrogen. The current ECH literature draws on these TCH studies and assumes that phenol ECH is also limited by surface adsorbed hydrogen [2]. Thus, most ECH work is done is acidic media, where the kinetics of surface adsorbed hydrogen formation are fastest on platinum [3]. HER, however, is also faster on platinum in acidic media [4], making it more difficult to achieve high faradaic efficiency. Because of this limited scope of investigation, the impact of electrolyte chemistry, i.e. pH, on ECH kinetics has only been sparingly investigated. In this work, we investigate a new pathway for enhanced rates at low overpotentials, driven by the acid-base chemistry of reactants and using electrolyte pH to promote dissociative adsorption. By tailoring the electrolyte pH based on the pKa of the reactant molecule, we can lower the barrier associated with the first hydrogenation step, improving overall reaction kinetics. We demonstrate this effect with phenol ECH at various pH electrolyte on low-index single crystal electrodes using rotating disk electrode voltammetry and chrono-amperometry with product analysis. The ECH of acetophenone and benzaldehyde are also included to compare the effect of different functionalities on the phenyl ring. We report on the structural sensitivity, influence of pH and resulting electric field effects, and present new mechanistic insights for phenol ECH. With these insights we propose methods to promote higher ECH rates at lower overpotentials. References: [1] J. Yan et al., "Characterizing Variability in Lignocellulosic Biomass: A Review," ACS Sustainable Chemistry & Engineering, vol. 8, no. 22, pp. 8059-8085, 2020, doi: 10.1021/acssuschemeng.9b06263. [2] N. Singh et al., "Aqueous phase catalytic and electrocatalytic hydrogenation of phenol and benzaldehyde over platinum group metals," Journal of Catalysis, vol. 382, pp. 372-384, 2020, doi: 10.1016/j.jcat.2019.12.034. [3] S. Intikhab, J. D. Snyder, and M. H. Tang, "Adsorbed Hydroxide Does Not Participate in the Volmer Step of Alkaline Hydrogen Electrocatalysis," ACS Catalysis, vol. 7, no. 12, pp. 8314-8319, 2017, doi: 10.1021/acscatal.7b02787. [4] I. Ledezma-Yanez, W. D. Z. Wallace, P. Sebastián-Pascual, V. Climent, J. M. Feliu, and M. T. M. Koper, "Interfacial water reorganization as a pH-dependent descriptor of the hydrogen evolution rate on platinum electrodes," Nature Energy, vol. 2, no. 4, 2017, doi: 10.1038/nenergy.2017.31.

Electrocatalytic Hydrogenation of Lignin-Derived Phenol into Alkanes by Using Platinum Supported on Graphite

Aqueous Phase Partial Hydrodeoxygenation of Lignin-Derived Phenols over Al2o3-Sio2 Microspheres Supported Rumn Multifunctional Catalyst: Synergic Effect among Ru, Mn and Al2o3-Sio2 Support

Electrocatalytic hydrogenation of lignin-derived compounds in heteropolyacid fluidized system

Lanthanum-promoted Pd/Al2O3 Catalysts for Liquid Phase in Situ Hydrogenation of Phenol to Cyclohexanone

Electrochemical Hydrogenation of Aromatic Hydrocarbons

Insights into the Electrochemical Hydrogenation of Phenol

Hydrogenolysis and Hydrodeoxygenation of Lignin in a Two-Step Process to Produce Hydrocarbons and Alkylphenols

pH Driven Pathways to Promote the Electrochemical Hydrogenation of Phenol and Other Aromatic Hydrocarbons

Robust PtRu catalyst regulated via cyclic electrodeposition for electrochemical production of cyclohexanol

Identification of the hydrogen utilization pathway for the electrocatalytic hydrogenation of phenol

Electrocatalytic hydrogenation of phenol on platinum-cobalt alloys

Electrocatalytic hydrogenation of phenol by active sites on Pt-decorated shrimp shell biochar catalysts: Performance and internal mechanism

Ternary Alloys Enable Efficient Production of Methoxylated Chemicals via Selective Electrocatalytic Hydrogenation of Lignin Monomers

Hydrodeoxygenation of Lignin-derived Phenols into Cycloalkanes by Atomically Dispersed Pt-Polyoxometalate Catalysts

Synergistic effects between electrocatalyst and electrolyte in the electrocatalytic reduction of lignin model compounds in a stirred slurry reactor

Electrocatalytic hydrogenation of mono- and dimeric lignin to hydrocarbons in fluidized electrocatalytic system

Hydrogenation of Lignin-Derived Phenolic Compound Eugenol over Ruthenium-Containing Nickel Hydrotalcite-Type Materials

Hydrodeoxygenation of Lignin-Derived Phenols into Alkanes over Carbon Nanotube Supported Ru Catalysts in Biphasic Systems

Electrocatalytic Upgrading of Lignin‐Derived Bio‐Oil Based on Surface‐Engineered PtNiB Nanostructure

Light-Irradiated Thermal Energy-Promoted Selective Phenol Hydrogenation on Cellulose-Supported Palladium Catalyst with Green Hydrogen

Simultaneous Phenol Removal and Resource Recovery from Phenolic Wastewater by Electrocatalytic Hydrogenation