Abstract:The thin-film composite (TFC) nanofiltration (NF) membrane is a novel kind of membrane that has been extensively studied in recent years and broadly applied in desalination and wastewater treatment. The improvement of separation performance by optimizing the structure and morphology of NF membranes can significantly reduce energy consumption and bring more economic benefits. In this work, glutaraldehyde (GA) was used to crosslink polyethyleneimine (PEI) and dextran nanoparticles (DNPs) to construct an interfacial coating interlayer on polysulfone (PSF) ultrafiltration (UF) substrate. Subsequently, the polyamide (PA) NF membranes were fabricated by interfacial polymerization (IP) between piperazine (PIP) and trimesoyl chloride (TMC). DNPs were semi-encapsulated in the PEI coating and the exposed nanoparticles would be embedded in the PA layer for forming interfacial channels after IP. The interlayer not only affected the adsorption and diffusion of aqueous phase monomers to form a thin membrane, but also improved the membrane density to prevent selective defects associated with the incorporation of nanoparticles. The pure water permeance of the interlayered-TFC NF membrane was determined as 313.3 Lm−2h−1MPa−1, which was approximately four-fold that of the pristine membrane. The retention rate of various divalent salts of the NF membrane also significantly improved, and the retention rate of Na2SO4 exceeded 99%. This innovative method of interlayer modification has exhibited great potential in rapid desalination and wastewater recovery, providing new possibilities for the preparation of industrial high-performance NF membranes.

High-performance nanofiltration membrane intercalated by FeOOH nanorods for water nanofiltration

High flux positively charged nanofiltration membranes prepared by UV-initiated graft polymerization of methacrylatoethyl trimethyl ammonium chloride (DMC) onto polysulfone membranes

Membranes with Negatively-Charged Nanochannels Fabricated from Aqueous Sulfonated Polysulfone Nanoparticles for Enhancing the Rejection of Divalent Anions

Preparation of Hybrid Nanofiltration Membranes Based on Schiff Base Reaction for Hard Water Softening

Graphene Oxide Based Membrane Intercalated by Nanoparticles for High Performance Nanofiltration Application

Designing nanofiltration hollow fiber membranes based on dynamic deposition technology

Nanofiltration membranes with enhanced performance by constructing an interlayer integrated with dextran nanoparticles and polyethyleneimine coating

Photo-Fenton assisted self-cleaning hybrid ultrafiltration membranes with high-efficient flux recovery for wastewater remediation

Ionic liquids tailored ultra-permeable antifouling nanofiltration membranes for water purification

Nanofiltration membrane fabrication by the introduction of polyhedral oligomeric silsesquioxane nanoparticles: Feasibility evaluation and the mechanisms for breaking “trade-off” effect

Highly permeable and acid-resistant nanofiltration membrane fabricated by in-situ interlaced stacking of COF and polysulfonamide films

Ultrafast loose nanofiltration membrane intercalated by in-situ grown nanoparticles for dye purification and reuse

Nanofiltration Membranes Via Co-Deposition of Polydopamine/polyethylenimine Followed by Cross-Linking

Polyoxometalates decoration combining with solvent activation for enhanced separation performance of nanofiltration membrane

In-situ incorporating zwitterionic nanocellulose into polyamide nanofiltration membrane towards excellent perm-selectivity and antifouling performances

Crown ether modulated high-performance nanofiltration membrane for water purification

Novel Nanofiltration Membrane with Ultrathin Zirconia Film As Selective Layer

Superhydrophobized Polyacrylonitrile/Hierarchicall-FeOOH Nanofibrous Membrane for High-salinity Water Treatment in Membrane Distillation

Polyhydroxy Group Functionalized Zwitterion for a Polyamide Nanofiltration Membrane with High Water Permeation and Antifouling Performance

Preparation of high-performance nanofiltration membranes with quaternized cross-linked microgels as intermediate layer

Separation performance of graphene oxide nanofiltration membrane intercalated by MWCNTs and α -Fe2O3 nanoparticles