Abstract:In this chapter, we discuss coarse-grained and atomistic molecular-dynamics simulation studies of the rheological properties of bulk polymer systems and polymer nanocomposites. Both systems contain monodispersed and non-crosslinked chain molecules. A multiscale strategy is applied to characterize the rheological behavior on different length scales of the systems structural organization. Fully atomistic simulations provide insights in rheological properties on smaller length scales than those accessible through coarse-grained simulations. Different approaches are utilized to obtain rheological moduli at these different length scales. At both levels of description, cyclic shear deformation is performed to characterize macroscopic properties of the systems before and after filler insertion. In the fully atomistic simulations of polyimide R-BAPB, passive microrheology approach is employed in addition to active rheology. To this end, a probe particle is immersed into the atomistic polymer matrix. Then, local rheological properties on the length scales at and beyond the Kuhn length are estimated. Results are compared with macroscopic rheological properties obtained by shear deformation. Additionally, the influence of the strain amplitude on the resulting rheological properties is examined. The reported coarse-grained simulations show a strong decrease of the nanocomposites storage modulus with increasing strain amplitude, which is accompanied by a maximum in the loss modulus (the so-called Payne effect); the onset of the softening is observed in the linear regime of deformation at strain amplitude of about 0.01. Moreover, the dependence of the storage modulus on the instantaneous strain exhibits both softening and hardening regimes, in agreement with recently reported [22] Large Amplitude Oscillatory Shear (LAOS) experiments. The simulations suggest that the observed hardening is caused by the shear-induced decrease of the non-affine diffusion of the polymer segments due to filler particles acting as effective crosslinks between polymeric chains and, hence, hindering diffusion. Moreover, the formation of “glassy” immobile layers at the nanoparticle interface strongly increases the storage modulus at low strain amplitudes. The strain softening with increasing strain amplitude is connected to the mobilization of these glassy layers and an increase in the dynamic heterogeneity of the polymer matrix. A breakup of the network structure plays a role as well.

In situ experimental investigation of fiber orientation kinetics during uniaxial extensional flow of polymer composites

Numerical simulation of fiber orientation kinetics and rheology of fiber-filled polymers in uniaxial extension

Experimental Validation of a Direct Fiber Model for Orientation Prediction

Fiber-Induced Crystallization in Elongational Flows

Orientation Distribution and Rheological Properties of Fiber Suspensions Flowing Through Curved Expansion and Rotating Ducts

Nanostructure and Mechanical Measurement of Highly Oriented Lamellae of Melt-Drawn HDPE by Scanning Probe Microscopy

Fiber Orientation Distribution and Rheological Properties of Fiber Suspension in a Turbulent Jet

Rheological Properties of Fiber Suspensions Flowing Through a Curved Expansion Duct

Effect of fiber orientation on spinning dynamics for liquid crystalline polymer solutions using mesoscopic theory

Influence of Reduced Graphene Oxide on the Rheological Response and Chain Orientation on Shear Deformation of High Density Polyethylene

Experimental investigation and modeling study of the fiber orientation behavior

Measuring orientation dynamics of carbon fibers by dielectric anisotropy in shear flows

Anisotropic Mechanical Response and Strain Localization of a Metallic Glassy-Fiber-Reinforced Polyethylene Terephthalate Fabric

Experimental investigation on in-plane shear behavior of E-glass fiber/epoxy laminated composites under different strain rates

Investigation of the effect of spirally stacked fiber reinforcement on the torsional behavior of a polymer composite rod by AE analysis

Unsteady rheo-optical measurements of uniaxially extending liquid polymers

Effect of fiber orientation on the failure behavior of a glass-fiber reinforced thermoplastic composite

Investigation of anisotropy effects in glass fibre reinforced polymer composites on tensile and shear properties using full field strain measurement and finite element multi-scale techniques

Linear Viscoelasticity of Polymers and Polymer Nanocomposites: Molecular-Dynamics Large Amplitude Oscillatory Shear and Probe Rheology Simulations

Rheology of concentrated suspension of fibers with load dependent friction coefficient

Physical analysis and statistical investigation of tensile and fatigue behaviors of glass fiber-reinforced polyester via novel fibers arrangement