Abstract:The proton-exchange membrane fuel cell (PEMFC) bipolar plate serpentine flow channel U-shaped region is prone to the accumulation effect, which poses serious difficulties for fuel cell water management. As a result, a deep understanding of water transport in the U-shaped region is essential to improve the fuel cell performance. Under this direction, in this work, the impact of the different microstructure parameters and initial conditions on water transport in the U-shaped region was compared with and without microstructure using the volume of the fluid method. On top of that, the velocity field distribution in the X-direction and the pressure drop distribution in the flow channel were also analyzed. From the acquired results, it was demonstrated that due to the secondary flow caused by the bending property of the microstructure, the droplet movement time in the U-shaped region was significantly shortened after the microstructure was added in the U-shaped region. The initial conditions strongly affected the droplet motion, and a larger contact angle enhanced the wall hydrophobicity to facilitate the droplet discharge. An increase in the droplet diameter led also to a rise in the windward area and shear force, which shortened droplet discharge time. Interestingly, if the waveform microstructure has too-large crests, gullies will be created that will impede the droplet motion and increase the amplitude of the droplet oscillation, resulting in excessive pressure drop in the flow channel. A too-large period led to increased droplet momentum loss, whereas a short period reduced the wall contact angle, which is not conducive to drainage. The microstructure spacing significantly affected the droplet motion, and the reduced spacing increased the airflow diffusion effect to accelerate the flow rate. The main focus of this work was led on the application of the microstructure in a U-shaped region of the serpentine flow channel, which is of great specific significance for droplet removal inside the flow channel.

Ex-situ experimental study on dynamic behaviors and detachment characteristics of liquid water in a transparent channel of PEMFC

Liquid Water Transport Characteristics and Droplet Dynamics of Proton Exchange Membrane Fuel Cells with 3D Wave Channel

Three-dimensional numerical simulations of water droplet dynamics in a PEMFC gas channel

Liquid water transport in gas flow channels of PEMFCs: A review on numerical simulations and visualization experiments

Dynamic Behaviour of Liquid Water Emerging from a GDL Pore into a PEMFC Gas Flow Channel

Investigation of Droplet Dynamic in PEMFCs Gas Diffusion Layer and Gas Channel with Micro-CT and Lattice Boltzmann Method

Effect of Three-Dimensional Geometric Structure and Surface Wettability on Two-Phase Flow Behavior in a Proton Exchange Membrane Fuel Cell Gas Flow Channel: Modeling and Simulation

Droplet dynamics in a proton exchange membrane fuel cell flow field design with 3D geometry

Numerical Investigation of Liquid Water Dynamics in Wave-Like Gas Channels of PEMFCs

Enhancing the Dynamic Performance of Proton Exchange Membrane Fuel Cells Through Two-Phase Flow Experimental Investigation

Three-Dimensional Lattice Boltzmann Simulation of Liquid Water Transport in Porous Layer of PEMFC.

Experimental and Simulation Analysis of Liquid Capillary Fingering Process in the Gas Diffusion Layer

In-situ Investigation of Bubble Dynamics and Two-Phase Flow in Proton Exchange Membrane Electrolyzer Cells

Effects of Surface Microstructures of Gas Diffusion Layer on Water Droplet Dynamic Behaviors in A Micro Gas Channel of Proton Exchange Membrane Fuel Cells

Lattice Boltzmann Simulations of Liquid Droplets Development and Interaction in A Gas Channel of A Proton Exchange Membrane Fuel Cell

Emergence of Droplets from a Bundle of Tubes into a Micro-Channel Gas Stream: Application to the Two-Phase Dynamics in the Cathode of Proton Exchange Membrane Fuel Cell

Numerical Simulation of Water Transport in a Proton Exchange Membrane Fuel Cell Flow Channel

Effects of Microstructure on Water Removal in the U-Shaped Region of PEMFC Serpentine Flow Channel

Three-dimensional Numerical Simulation of Bubble Dynamics and Design Optimization of Microchannel in Proton Exchange Membrane Water Electrolyzers

Droplets dynamics theory and micro-flow field experiments of improving self-humidifying feature and maximum power density in fuel cells

Droplet and Percolation Network Interactions in a Fuel Cell Gas Diffusion Layer